Instruction/ maintenance manual of the product 465630003 Thermos
Go to page of 32
WARNING CA UTION Some parts may contain sharp edges – especially as noted in the manual! Wear protective gloves if necessary. Failure to follow all manufacturer’s instructions could result in fire or explosion which could cause property damage, personal injury or death.
2 • Fire & Ice D ANGER WARNING CA UTION FOR YOUR SAFETY 1. Do not store or use gasoline or other flammable vapors and liquids in the vicinity of this or any other appliance. 2. An LP tank not connected for use shall not be stored in the vicinity of this or any other appliance.
Fire & Ice • 3 LP (Liquefied Petroleum Gas) • For Your Safety • LP gas is highly flammable and may ignite unexpectedly when mixed with air. Is nontoxic, odorless and colorless when produced. , LP gas has been given an odor (similar to rotten cabbage) so that it can be smelled.
4 • Fire & Ice Warranty THERMOS GRILLS Consumer Warranty / P.O. Box 1240 Columbus, GA 31902-1240 Thermos warrants to the original consumer-purchaser that this product shall be free from defects .
Fire & Ice • 5 For Your Safety .............................................................2 Safety Symbols LP (Liquefied Petroleum Gas) .................................................3 Grill Service Center Installation Safety Precautions Warranty Information Warranty .
6 • Fire & Ice FEATURES Heat indicator Level indicator Viewing glass Bottle opener Ignitor Lift handle Pull handle/Cooler shelf Cooler shelf support Foot pedal Cooler lid.
Fire & Ice • 7 FEATURES Tool set Grease bottle Lift handle Storage net Cup/can holders Tool holders Match lighting stick.
8 • Fire & Ice PARTS LIST Key Quantity Description Part Number 1 1 T orsion Bar 21-6047-009-200 2 2 Upper Hinge 22-6047-004-200 3 1 Grill Lid 65-6048-018-200 4 2 Side Lid Spacer 13-6047-397-200 .
Fire & Ice • 9 PARTS DIAGRAM 1 2 2 3 7 6 8 9 10 11 12 13 14 18 15 16 17 15 16 28 27 26 24 25 23 22 20 21 19 43 5 4 4 44 44 44.
10 • Fire & Ice PARTS DIAGRAM 29 31 32 32 33 34 35 38 37 39 40 41 30 36 42.
Fire & Ice • 11 ASSEMBLY Pedal To raise gril l... PRESS and foot pedal on front of cooler. Foot pedal once the grill begins to rise so that the grill will lock into position. RELEASE MUST BE RELEASED Press Release Slide cooler lid back to open and lift grill lid to remove packed components.
12 • Fire & Ice To lower grill and begin assembly . . . Make sure cooler lid is in the closed position. PRESS foot pedal and push grill down by pressing on of grill lid. foot pedal BEFORE grill reaches the cooler so that it will lock into position.
Fire & Ice • 13 Attach grease bottle by sliding bottle bracket over tabs on left side of plinth. Twist 1 lb. LP gas cylinder (sold separately) into regulator.
14 • Fire & Ice PRESS and foot pedal on front of cooler. Foot pedal once the grill begins to rise so that the grill will lock into position. RELEASE MUST BE RELEASED To install regulator/cylinde r... 1. Push and hold regulator lock to right. 2. Push and hold the gas interlock downward.
Fire & Ice • 15 Attach side shelves by sliding shelf rods into holes on each side of grill. NOTE: Shelf with regulator cut-out attaches to right side.
16 • Fire & Ice The pull handle on your cooler may converted for use as a shelf by utlizing the built-in support in the handle. To use the pull handle as a shel f... 1. Raise pull handle to horizontal position. 2. Lower the support wire (built into handle).
Fire & Ice • 17 TABLETOP MODE To remove grill from cooler for tabletop u s e... Begin with grill in the lowered position. Grasp the plinth on each side (see arrows) and lift grill from cooler. Beneath the plinth, unfold the wire legs. Legs will lock into position when fully extended.
18 • Fire & Ice NO TE: MUST Regulator and gas cylinder be removed from grill before placing grill onto cooler. Align posts beneath plinth with holes on top of cooler and slide grill downward onto cooler. To close legs and return grill to coole r.
Fire & Ice • 19 USE AND CARE Propane Cylinder Use (1 lb. Disposable) • • • • Use only cylinder marked “Propane Fuel”. Size should be 4” diameter , 8” height, or 3” diameter , 10” height. Save cylinder cap and reinstall when not in use.
20 • Fire & Ice Propane Cylinder Use (20 lb. Refillable) The 20 lb. LP tank used with your grill must meet the following requirements: • • • Use only tanks equipped with this type of valve.
Fire & Ice • 21 Leak Testing (20 lb. Refillable) IMPORT ANT! For your safety • • • • Use mild soap and water. Do not use household cleaning agents. (A) Leak test must be repeated each time LP tank is exchanged or refilled. Do not smoke during leak test.
22 • Fire & Ice Connecting The Adapter Hose To The LP Tank (continued) 5. Hold hose end, insert nipple (A) into LP tank valve. Hand tighten coupling nut, (B) so as not to cross thread the connection. holding connector in a straight line with LP tank valve Position coupling nut and hose-end as shown for proper connection to LP tank valve.
Fire & Ice • 23 WARNING • Do not use grill until leak checked. • If leak is detected at any time, STOP and call the Fire Department. • If you cannot stop a gas leak, close LP tank valve and call LP gas supplier or your fire department! immediately Leak Testing Valves, Hoses and Regulator Turn grill control knob to off.
24 • Fire & Ice For Safe Use Of Your Grill: • • • • • • • Operate grill with 1 lb. cylinder in correct position as shown in . • Always remove 1 lb. cylinder from grill when transporting. • Operate grill with 20 lb. cylinder in correct position as show in .
Fire & Ice • 25 Safety Tips Ignitor Check Regulator/Valve must be in “Off” position. Ignitor Lighting s s s s s s s s The use of alcohol, prescription or nonprescription drugs may impair the consumer ’ s ability to properly assemble or safely operate the appliance.
26 • Fire & Ice Match Lighting 1. Push Regulator/V alve in and turn counterclockwise to LIGHTING POSITION. 2. Attach match to match lighting stick, light match. 3. Insert match lighting stick into vent hole at rear of grill. WARNING If burner does not light within 5 seconds, turn knob to OFF, wait 5 minutes, try again.
Fire & Ice • 27 General Grill Cleaning Do not apply a caustic grill/oven cleaner to painted surfaces. Plastic Side Shelves: • Non-Stick Cooking Surface: • Grease Bottle: • Do not mistake brown or black accumulation of grease and smoke for paint.
28 • Fire & Ice Non-Stick Cooking Surface Use and Care. Food Safety Clean: Separate: Cook: Chill: How to Tell if Meat is Grilled Thoroughly • • • • • • Use only plastic tools. • Do not cut food on surface. • Do not put pots or pans on surface.
Fire & Ice • 29 Troubleshooting Problem Burner will not light using ignitor. Burner will not match light. Flames blow out. Flashback (fire in burner tube) Possible Cause Electrode and burner are wet. Electrode cracked or broken, "sparks at crack".
30 • Fire & Ice Recreational Vehicles THERMOS GRILLS has approved use of the Fire & Ice with specific recreational vehicles subject to the following provisions: • The is to be directly connected to an additional 20 lb. or 30 lb. DOT/TC LP tank mounted on the RV .
Fire & Ice • 31.
® A Division of W.C. Bradley Company P .O. Box 1240 Columbus, GA 31902–1240 Certified Grill Parts And Accessories®, Char-Broil and Design®, Char-Broil (Gas Grill Briquettes)®, Char-Diamonds®, C.
An important point after buying a device Thermos 465630003 (or even before the purchase) is to read its user manual. We should do this for several simple reasons:
If you have not bought Thermos 465630003 yet, this is a good time to familiarize yourself with the basic data on the product. First of all view first pages of the manual, you can find above. You should find there the most important technical data Thermos 465630003 - thus you can check whether the hardware meets your expectations. When delving into next pages of the user manual, Thermos 465630003 you will learn all the available features of the product, as well as information on its operation. The information that you get Thermos 465630003 will certainly help you make a decision on the purchase.
If you already are a holder of Thermos 465630003, but have not read the manual yet, you should do it for the reasons described above. You will learn then if you properly used the available features, and whether you have not made any mistakes, which can shorten the lifetime Thermos 465630003.
However, one of the most important roles played by the user manual is to help in solving problems with Thermos 465630003. Almost always you will find there Troubleshooting, which are the most frequently occurring failures and malfunctions of the device Thermos 465630003 along with tips on how to solve them. Even if you fail to solve the problem, the manual will show you a further procedure – contact to the customer service center or the nearest service center
