Instruction/ maintenance manual of the product 300 Therma-Stor Products Group
Go to page of 11
Owner’ s Manual — Phoenix 300 Installation, Operation and Ser vice Instr uctions 1 www .ther mastor .com • sales@thermastor .com T oll-F ree 1-800-533-7533 Read and Sav e These Instr uctions Pho.
2 www .ther mastor .com • sales@ther mastor .com T oll-F ree 1-800-533-7533 1 Specifications Par t No. 4022599 Pow er 12 amps, 115 V ac, Grounded W ater 176 pints/day @ AHAM 80°F , 60% RH Removal 304 pints/day maximum @ 90°F , 90% RH Blower 540 CFM without external ducting Refrigerant 2 lbs.
3 www .ther mastor .com • sales@ther mastor .com T oll-F ree 1-800-533-7533 2.3 Electrical Requirements The Phoenix 300 can be plugged into a grounded 15 Amp circuit. At 80°F , 60% RH, it draws 11.e Amps. Due to the high percentage of a 15 Amp circuit’ s capacity that the unit uses, the circuit should be dedicated to r unning it only .
4 www .ther mastor .com • sales@ther mastor .com T oll-F ree 1-800-533-7533 5. Replace the cover . Change the timer pegs back to the original pattern for use above 50°F . 2.11 Low Pressure Control If the low side refrigerant pressure drops to 15 PSIG, the low pressure control opens and shuts off the compressor and blower .
5 www .ther mastor .com • sales@ther mastor .com T oll-F ree 1-800-533-7533 coil where it absorbs heat from the incoming air and evaporates. The evaporator operates in a flooded condition, which means that all the evaporator tubes contain liquid refrigerant during normal operation.
6 www .ther mastor .com • sales@ther mastor .com T oll-F ree 1-800-533-7533 Evaporator coil frosted continuously , low dehumidifying capacity . 1. Defrost thermostat loose or defective (Sec. 2.10 and 4.7). 2. Defrost timer incorrectly set or defective (Sec.
7 www .ther mastor .com • sales@ther mastor .com T oll-F ree 1-800-533-7533 and water . These contaminants must be carefully removed otherwise even small residues will attack replacement compressor motors and cause failures.
8 www .ther mastor .com • sales@ther mastor .com T oll-F ree 1-800-533-7533 Figure 3: Electrical schematic of Phoenix 300 5 Wiring Diagram 4.9 Rela y The contacts of the single pole, single throw relay complete the power circuit to the compressor . The contacts are closed when power is pro vided to the relay coil via the control circuit.
9 www .ther mastor .com • sales@ther mastor .com T oll-F ree 1-800-533-7533 Item Par t No. Qty . Description 1 4021818 1 Accumulator 2 4022636 1 Air Filter , Pleated, 2” x 20” x 20” 4022614 1 .
10 www .ther mastor .com • sales@ther mastor .com T oll-F ree 1-800-533-7533 This page intentionally left blank..
11 www .ther mastor .com • sales@ther mastor .com T oll-Free 1-800-533-7533 Phoenix 300 Dehumidifier Limited W ar ranty W ar rantor : Therma-Stor LLC PO Box 8680 Madison, WI 53708 T elephone: 1-800.
An important point after buying a device Therma-Stor Products Group 300 (or even before the purchase) is to read its user manual. We should do this for several simple reasons:
If you have not bought Therma-Stor Products Group 300 yet, this is a good time to familiarize yourself with the basic data on the product. First of all view first pages of the manual, you can find above. You should find there the most important technical data Therma-Stor Products Group 300 - thus you can check whether the hardware meets your expectations. When delving into next pages of the user manual, Therma-Stor Products Group 300 you will learn all the available features of the product, as well as information on its operation. The information that you get Therma-Stor Products Group 300 will certainly help you make a decision on the purchase.
If you already are a holder of Therma-Stor Products Group 300, but have not read the manual yet, you should do it for the reasons described above. You will learn then if you properly used the available features, and whether you have not made any mistakes, which can shorten the lifetime Therma-Stor Products Group 300.
However, one of the most important roles played by the user manual is to help in solving problems with Therma-Stor Products Group 300. Almost always you will find there Troubleshooting, which are the most frequently occurring failures and malfunctions of the device Therma-Stor Products Group 300 along with tips on how to solve them. Even if you fail to solve the problem, the manual will show you a further procedure – contact to the customer service center or the nearest service center
