Stanley Black & Decker MBX15 Power Hammer manual

Summary of contents each page of manual

Page 1

www .stanleyhydraulic.com USER MANUAL MBX15 H ydRAULic M oUNtEd B REAkER MBX15.
Page 2

2 ► MBX15 User Manual Read Manual Wear Breathing Protection Wear Hearing Protection Wear Eye Protection Do not operate the breaker unless the following safety instructions have been thoroughly read .
Page 3

MBX15 User Manual ◄ 3 IMPORT ANT T olloutaProductW arrantyRecordingform,andforinformationonyourwarranty , visitStanleyhydraulics.comandselecttheCompanytab,W arranty . ( NOTE: T hewarrantyrecordingformmustbesubmittedtovalidatethewarranty).
Page 4

4 ► MBX15 User Manual T ooloperatorsand maintenancepersonnel mustalways comply with the safety precautions given in this manu - al and on the decals and tags attached to the tool and hose. These safety precautions are given for your safety .
Page 5

MBX15 User Manual ◄ 5 • Makesure allcontrols(levers andpedals) areinthe NEUTRAL positionbeforestartingthecarrier . • While operatingthe breaker andcarrier , keephands andfeetonthecontrolsatalltimes.
Page 6

6 ► MBX15 User Manual Alwaysobservesafetysymbols.Theyareincludedforyoursafetyandfortheprotectionofthetool.
Page 7

MBX15 User Manual ◄ 7 Shownbelow andon thenext page aredecals andstickers foundon theequipment thatprovide importantinforma - tion.Replacedecalsandstickerswhentheyarenolongerlegible.
Page 8

8 ► MBX15 User Manual PREP ARA TION FOR OPERA TION NITROGEN CHARGE Thebreakerhasbeenproperlychargedwithnitrogenat thefactory and isready touse (see page20) forcharg - inginformation.
Page 9

MBX15 User Manual ◄ 9 Piston not against toolbitleavingspace betweenthepiston andbit. T oolStop LowerBushing T oolBit GreaseWill FillThis Space Figure 2. SECURING THE TOOL 1. Laythebreakerinahorizontalpositiontoinstallthe tool bit.
Page 10

10 ► MBX15 User Manual PREP ARA TION FOR USE Read the section in this manual titled PREP ARA TION FOR USE before operating a breaker .
Page 11

MBX15 User Manual ◄ 1 1 BREAKING The operator should note the sound of the blow when the breaker is running. With experience, the operator will be able totell the difference between agood solid blow and a hollow sounding blow .
Page 12

12 ► MBX15 User Manual Excessive sideforce cocksthe tool inits bore,pre-vents proper movement and causes premature tool shank and bushing wear .
Page 13

MBX15 User Manual ◄ 13 UNDERW A TER USE Nopartofthebreakermaybesubmergedinwater unlessanairapplicationkitisused.Underwater usageofthebreakerwithoutairapplicationwill causeinternaldamagetothebreaker .
Page 14

14 ► MBX15 User Manual EACH DA Y • Checkfor looseor missingfasteners.Tightenorre - placeasneeded. • Inspecttoolretainingpinsandpocketsforwear . • Check for hydraulic leaks at all ttings and hoses.
Page 15

MBX15 User Manual ◄ 15 Worn-out retainer pin(s) will cause uneven loading on the pin(s) themselves, causing failure of the tool or re - tainer pin(s).This will also cause excessive wearto the frontbushing(s).
Page 16

16 ► MBX15 User Manual In its most extreme forms, the combination of surface damageand severebendingcan quickly breakeven the bestworkingsteels. The illustrations below show examples of severe stress breaks.
Page 17

MBX15 User Manual ◄ 17 T OOL F AILURE COVERED UNDER W ARRANTY INTERNAL MA TERIAL FLA W Thisfailure occurs when aforeign material is rolled into the steel during the manufacturing process, causing an imperfection in the internal material aw grain.
Page 18

18 ► MBX15 User Manual Stanley Breakers are available with several differenttypes of tool bits.The most common are the moil, chisel and theblunt.
Page 19

MBX15 User Manual ◄ 19 Ifsymptomsofpoorperformancedevelop,thefollowingchartcanbeusedasaguidetocorrecttheproblem.
Page 20

20 ► MBX15 User Manual Thetools requiredto chargethe breaker areshown be - low . The 33464 adapter and 33300 adapter assembly can be obtainedindividually orin akit (P/N33465).
Page 21

MBX15 User Manual ◄ 21 MBX15 TORQUE T ABLE ITEM NO. ILLUSTRA TION DESCRIPTION APPL Y FT/ LB NM 3 POWERCELL CHARGE VA LV E LOCTITE™ 242 75 101 8 POWERCELL O-RINGPLUG LOCTITE™ 24.
Page 22

22 ► MBX15 User Manual The correct performance of this procedure will verify if theauxiliarycircuitofthecarrieris adequatetoproperly operateaStanleyattachment. This procedure is generic in form.
Page 23

MBX15 User Manual ◄ 23 NOTE: Weights, dimensions and operating specications listed on this sheet are subject to change without no - tice. Where specications are criti - caltoyourapplication,pleasecon - sultthefactory .
Page 24

24 ► MBX15 User Manual 72330T ie RodKit MBX15 POWER CELL ILLUSTRA TION When installing the tool retainer pin (item 28) make surethe rubberplug (item 35) is fully seated. Therubberplug MUST be installed BELOW FLUSH toproperlysecurethe pin.
Page 25

MBX15 User Manual ◄ 25 ITEM P/N QTY DESCRIPTION 1 71592 1 MAIN ACCUMULA TOR 2 71593 3 O-RING 3 68679 2 CHARGEV AL VE 4 68680 2 PLUG 5 68681 2 O-RING 6 71594 1 CYLINDER 7 71595 1 PISTON 8 71596.
Page 26

26 ► MBX15 User Manual ITEM P/N QTY DESCRIPTION 1A 71 160 1 MBX15POWERCELLW/CROSSCUT  TOOL BIT 1 66680 1 UPPERBUMPER 72331 1 HOUSINGFLANGEBOL TKIT(INCL ONE ITE.
Page 27

MBX15 User Manual ◄ 27 DECLARATION OF CONF ORM ITY ÜBEREINSTIMM UNGS - ERKLARUNG DECLARATION DE CONFOR MITE CEE DECLARACION DE CONFO RMIDAD DICHIARAZIONE DI CONFORM ITA Hydraulic Tools _______ ____.
Page 28

StanleyHydraulicT ools 3810SENaefRoad Milwaukie,Oregon97267-5698USA (503)659-5660 Fax(503)652-1780 www .stanleyhydraulics.

Read the Stanley Black & Decker MBX15 manual - avoid problems

An important point after buying a device Stanley Black & Decker MBX15 (or even before the purchase) is to read its user manual. We should do this for several simple reasons:

to know how to properly use the device
to know how to perform maintenance/ periodic checks of correct operation of the product Stanley Black & Decker MBX15
to know what to do in case of failure Stanley Black & Decker MBX15

If you have not bought Stanley Black & Decker MBX15 yet, this is a good time to familiarize yourself with the basic data on the product. First of all view first pages of the manual, you can find above. You should find there the most important technical data Stanley Black & Decker MBX15 - thus you can check whether the hardware meets your expectations. When delving into next pages of the user manual, Stanley Black & Decker MBX15 you will learn all the available features of the product, as well as information on its operation. The information that you get Stanley Black & Decker MBX15 will certainly help you make a decision on the purchase.

If you already are a holder of Stanley Black & Decker MBX15, but have not read the manual yet, you should do it for the reasons described above. You will learn then if you properly used the available features, and whether you have not made any mistakes, which can shorten the lifetime Stanley Black & Decker MBX15.

However, one of the most important roles played by the user manual is to help in solving problems with Stanley Black & Decker MBX15. Almost always you will find there Troubleshooting, which are the most frequently occurring failures and malfunctions of the device Stanley Black & Decker MBX15 along with tips on how to solve them. Even if you fail to solve the problem, the manual will show you a further procedure – contact to the customer service center or the nearest service center

Stanley Black & Decker MBX15 manual

Share URL

Similar manuals

Share URL

Similar manuals

Summary of contents each page of manual

Page 1

Page 2

Page 3

Page 4

Page 5

Page 6

Page 7

Page 8

Page 9

Page 10

Page 11

Page 12

Page 13

Page 14

Page 15

Page 16

Page 17

Page 18

Page 19

Page 20

Page 21

Page 22

Page 23

Page 24

Page 25

Page 26

Page 27

Page 28

Read the Stanley Black & Decker MBX15 manual - avoid problems

Other manuals from the category Power Hammer

Makita 35 mm HR3520 38 mm HR3850

Makita 8271D

Makita 8281D

Makita 8381D

Makita 8391D

Makita BDF451RFE

Makita BHR200

Makita BHR200

Makita BHR200SH

Makita BHR202