Instruction/ maintenance manual of the product 944.36201 Sears
Go to page of 24
Owner's Manual ROTARY LAWN MOWER 3.5 Horsepower 20" Side Discharge Model Number 944.362010 CAUTION: Read and follow all Safety Rules and Instructions before operating this equipment Sears Canada, Inc.
Warranty ................................................. 2 Safety Rules ........................................ 2-4 Assembly / Pre-Operation ................... 6-7 Operation ........................................... 8-10 Maintenance Schedule ...
• Do not operate the mower when barefoot or wearing open sandals. Always wear substantial foot wear. • Do not pull mower backwards unless absolutely necessary. Always look down and behind before and while moving backwards. • Do not operate the mower without proper guards, plates, grass catcher or other safety protective devices in place.
• Stop and inspect the equipment if you strike an object. Repair, if necessary, before restarting. • Never attempt to make wheel height adjustments while the engine (motor) is running. • Grass catcher components are subject to wear, damage, and deterioration, which could expose moving parts or allow objects to be thrown.
Parts Bag contents shown full size (4) Hex Bolts 3/8-16 x 1 (4) Washers 7/8" @ (4) Flange Locknuts 3/8-16 (2) Washers 1-1/4" (4) Shoulder Bolts (2) Hex Bolts1/4-20 x 3/4 (4) Locknuts 3/8 - 1.
_CAUTION: Do not operate this mower without the discharge guard or an entire approved grass catcher in place. These guards are for your protection and are required by the American National Standards Institute and Consumer Products Safety Commission.
1-1/4" (rear wheel only) Mower housing Shoulder bolt 3/8-16 Wheel Locknut ASSEMBLE DISCHARGE GUARD 1. Place discharge guard on top of lawn mower discharge opening. 2. Install two (2) 1/4-20 x 3/4 hex bolts through housing and discharge guard, 3. Install two (2) 3/4" diameter washers and two (2) 1/4-20 Iocknuts.
KNOW YOUR LAWN MOWER READ THIS OWNER'S MANUALAND ALL SAFETY RULES BEFORE OPERATING YOUR LAWN MOWER. Compare the iliustralJons with your lawn mower to familiarize yourself with the location of various controls and adjustments. Save this manual for future reference.
The operation of any lawn mower can result in foreign objects thrown into the eyes, which can result in severe eye damage. Always wear safety glasses or eye shields while operating your lawn mower or performing any adjustments or repairs. We recommend standard safety glasses or a wide vision safety mask worn over spectacles.
ADD GASOLINE • Fill fuel tank to bottom of tank filler neck. Do not overfill. Use fresh, clean, regular unleaded gasoline with a minimum of 87 octane. Do not mix oil with gasoline. Purchase fuel in quantities that can be used within 30 Adays to assure fuel freshness.
.A,NTENANOESC.EDULE AS YOU COMPLETE REGULAR SERVICE f__ _()_r_._C-Z SERVICE DATES Check for Loose Fasteners Ikf I1_ Clean/Inspect Grass Catcher , (If Equipped) t/ _ M Clean Lawn Mower O Clean Under Dr.
PRODUCT SPECIFICATIONS Serial Number: Date of Purchase: Gasoline Capacity / Type: 1.0 Quarts (unleaded regular) Oil Type (API-SF-SJ): SAE 30 (above 32°F); SAE 5W-30 (below 32°F) Oil Capacity: 20 Ounces Spark Plug (Gap: .030") Champion RJ19LM Blade Bolt Torque: 35-40 ft.
GRASS CATCHER (if purchased as an accessory) • The grass catcher may be hosed with water, but must be dry when used. • Check your grass catcher often for damage or deterioration. Through normal use it will wear. If catcher needs replacing, replace only with a manufacturer approved replacement catcher.
MUFFLER Inspect and replace corroded muffler as it could create a fire hazard and/or dam- age. SPARK PLUG Replace spark plugs at the beginning of each mowing season or after every 100 hours of operation, whichever occurs first. Spark plug type and gap setting are shown in "PRODUCT SPECIFICATIONS" in Maintenance section of this manual.
Immediately prepare your lawn mower for storage at the end of the season or if the unit will not be used for 30 days or more. LAWN MOWER When lawn mower is to be stored for a period of time, clean it thoroughly, remove all dirt, grease, leaves, etc. Store in a clean, dry area.
TROUBLESHOOTING - See appropriate section in manual unless directed to a Sears Service Center. PROBLEM CAUSE CORRECTION Does not start 1, Dirty air filter. 1. Clean/replace air filter. 2. Out of fuel. 3. Stale fuel. 4. Water in fuel. 5. Spark plug wire is disconnected.
TROUBLESHOOTING - See appropriate section in manual unless directed to a Sears Service Center. CAUSE PROBLEM Loss of power Poor cut - uneven Excessive vibration Starter rope hard to pull 1. Rear of housing or blade dragging in heavy grass. 2. Cutting too much grass.
ROTARY LAWN MOWER -- MODEL NUMBER 944.362010 11 12 14 22 39 2O 21 24 24 f 2O 19 _ 23 21 _ 22 13 22 33 35.
ROTARY LAWN MOWER -- MODEL NUMBER 944.362010 KEY PART NO. NO. 1 86902 2 179585 3 750097 4 172146X479 5 63601 7 169711X479 8 163799 9 7435O424 10 86899X004 (.
BRIGGS & STRATTON 4-CYCLE ENGINE MODEL NUMBER 9E902-0214-B1 ] 1058 OWNER'S MANUAL I 524 83_ _ I 358 GASKET SET _ 524_ 190_ 190A_ 670.
BRIGGS & STRATTON 4-CYCLE ENGINE MODEL NUMBER 9E902-O214-B1 901 973 393 _ 39ol 612 617 188 _22_ I 1036 LABEL-EMISSION I 1 ._.m 65y 592 ® 58_ 6o_ 689 621 745A_ 7451 s29_ 772T 365 925 729 _3 615 °.
BRIGGS & STRATTON 4-CYCLE ENGINE MODEL NUMBER 9E902-0214-B1 K_-Y PART NO. NO. DESCRIPTION K]EY PART NO. NO. DESCRIPTION 1 697401 Cylinder Assembly 337 802592 2 399269 Bushing 356 692390 3 299819 .
SERVICE NOTES 23.
Just Call: 1-800-4-MY-HOME ® (1-800-469-4663) 24 hours a day, 7 days a week For the repair of major brand appliances In your own home... no matter who made it, no matter who sold it! For your nearest Sears Parts and Service location, to bring in products like vacuums, lawn equipment and electronics.
An important point after buying a device Sears 944.36201 (or even before the purchase) is to read its user manual. We should do this for several simple reasons:
If you have not bought Sears 944.36201 yet, this is a good time to familiarize yourself with the basic data on the product. First of all view first pages of the manual, you can find above. You should find there the most important technical data Sears 944.36201 - thus you can check whether the hardware meets your expectations. When delving into next pages of the user manual, Sears 944.36201 you will learn all the available features of the product, as well as information on its operation. The information that you get Sears 944.36201 will certainly help you make a decision on the purchase.
If you already are a holder of Sears 944.36201, but have not read the manual yet, you should do it for the reasons described above. You will learn then if you properly used the available features, and whether you have not made any mistakes, which can shorten the lifetime Sears 944.36201.
However, one of the most important roles played by the user manual is to help in solving problems with Sears 944.36201. Almost always you will find there Troubleshooting, which are the most frequently occurring failures and malfunctions of the device Sears 944.36201 along with tips on how to solve them. Even if you fail to solve the problem, the manual will show you a further procedure – contact to the customer service center or the nearest service center
