Instruction/ maintenance manual of the product US-1 EBZ5100Q RedMax
Go to page of 18
US-1 EBZ5100Q U S OWNER 'S/ OPERA T OR'S MANUAL BA CKP A CK BLO WER 848-L3N-93A1 (909) W ARNING The engine exhaust from this product contains chemicals known to the State of California to cause cancer, birth defects or other reproductive harm.
US-2 EBZ5100Q SAFETY FIRST Instructions contained in warnings within this manual and warning seals marked with a symbol on the blower concern critical points which must be taken into consideration to prevent possible serious bodily injury, and for this reason you are requested to read all such instructions carefully and follow them without fail.
US-3 EBZ5100Q U S 1. Parts location ■ MODEL EBZ5100Q Dimensions (L x W x H) mm (in) ···············································································401x483x495 (15.
US-4 EBZ5100Q For safe operation and maintenance, symbols are carved in relief on the machine. According to these indications, please be careful not to make a mistake.
US-5 EBZ5100Q U S • The blower is used for blowing away leaves and other debris on the ground. When operating the blower, the operater must stand with both feet firmly on the ground.
US-6 EBZ5100Q 5. For safe operation 2. Before starting operation, always make sure to check if any obstacles are left inside the volute case and net. The obstacles may cause damage on fan and volute case and serious injury. 3. Check to see if the shock-absorbing rubber mount has become cracked or otherwise damaged.
US-7 EBZ5100Q U S 5. For safe operation ordinances. 2. To reduce sound levels, limit the number of pieces of equipment used at any one time. 3. Operate power blowers at the lowest possible throttle speed to do the job. 4. Check your equipment before operation, especially the muffler, air intakes and air filters.
US-8 EBZ5100Q 6. Set up ■ BLOWER TUBES 1. Connect the blower and swivel joint with flexible hose. Clamp both ends of the flexible hose securely with the hardware supplied with the unit. 2. Align the protrusion and the groove provided on the tube ends and twist the tube until connection is locked up.
US-9 EBZ5100Q U S 7. Fuel lines or fuel tank of the engine. • Failures caused by operating engines on gasoline with octane rating lower than 89 are not covered by the RedMax Two- Stroke engine warranty.
US-10 EBZ5100Q 7. Fuel test standard has been discontinued by API in 1995 and it no longer exists. • Gasoline/Oil mixture Storage Recommendations Store your gasoline or gasoline/oil mixture in a cool dry area in a tightly sealed approved container to limit the entry of moisture and additional air (oxygen).
US-11 EBZ5100Q U S 8. Operation ■ CONTROL ARM •H old the upper end of the control arm in hand and, while pulling it away from the unit, rotate arm forward (anti- clockwise as the arrow direction) until it clicks. (The first position) And if you want, you can rotate arm more forward until it clicks.
■ ADJUSTING IDLE SPEED • The idling speed is set for 2200 rpm at the factory. If it is necessary to adjust the idle speed, use the adjustment screw on the top side of carburetor. (1) Idling Adjustment Screw ■ STOPPING ENGINE 1. Move the throttle lever to the idling position and run the engine for a half minute.
US-13 EBZ5100Q U S Maintenance, replacement, or repair of the emission control device and systems may be performed by any non-road engine repair establishment or individual. 9. Maintenance F13 F14 (1) (2) (3) (5) (4) F15 Make sure that the engine has stopped and is cool before performing any service to the blower.
US-14 EBZ5100Q held by three bolts (F18 (2)). (Fastening Torque : 8 to 12 N·m) • Also make sure that the speak arrester and the diffuser are properly attached with four bolts (F18 (1)). (Fastening Torque : 2 to 3 N·m) • Even if one of seven bolts is loose, it may result in engine catching on fire.
US-15 EBZ5100Q U S 9. Maintenance ■ IGNITION COIL AIR GAP INSPECTION • If the gap is out of standard or when installing the coil or rotor, adjust the air gap between the ignition coil and the iron core of the rotor. Air Gap: 0.40mm (0.35 ~ 0.45mm) 0.
US-16 EBZ5100Q BEFORE STORING THE BLOWER: 1. Drain a fuel tank and push the primer bulb until it becomes empty of fuel. 2 .Remove the spark plug and drop a spoonful of 2-cycle oil into the cylider. Crank the engine several time and install the spark plug.
US-17 EBZ5100Q U S The EPA (U.S. Environmental Protection Agency), CARB (California Air Resources Board), Environment Canada and RedMax are pleased to explain the emissions control system's warranty on your 2009 and later small off-road engine. In U.
US-18 EBZ5100Q warranty is warranted for the remaining warranty period. Any warranted part that is scheduled only for regular inspection in the maintenance schedule will be warranted for a period of two years.
An important point after buying a device RedMax US-1 EBZ5100Q (or even before the purchase) is to read its user manual. We should do this for several simple reasons:
If you have not bought RedMax US-1 EBZ5100Q yet, this is a good time to familiarize yourself with the basic data on the product. First of all view first pages of the manual, you can find above. You should find there the most important technical data RedMax US-1 EBZ5100Q - thus you can check whether the hardware meets your expectations. When delving into next pages of the user manual, RedMax US-1 EBZ5100Q you will learn all the available features of the product, as well as information on its operation. The information that you get RedMax US-1 EBZ5100Q will certainly help you make a decision on the purchase.
If you already are a holder of RedMax US-1 EBZ5100Q, but have not read the manual yet, you should do it for the reasons described above. You will learn then if you properly used the available features, and whether you have not made any mistakes, which can shorten the lifetime RedMax US-1 EBZ5100Q.
However, one of the most important roles played by the user manual is to help in solving problems with RedMax US-1 EBZ5100Q. Almost always you will find there Troubleshooting, which are the most frequently occurring failures and malfunctions of the device RedMax US-1 EBZ5100Q along with tips on how to solve them. Even if you fail to solve the problem, the manual will show you a further procedure – contact to the customer service center or the nearest service center
