Instruction/ maintenance manual of the product SGCZ2450S RedMax
Go to page of 19
US-1 SGCZ2450S U S OWNER 'S/ OPERA T OR'S MANUAL RECIPR OCA T ORS 848-JN7-93A0 (909) APPLICABLE SERIAL NUMBERS : DRIVE UNIT 90800101 and up ENGINE UNIT 90800101 and up W ARNING The engine exhaust from this product contains chemicals known to the State of California to cause cancer, birth defects or other reproductive harm.
US-2 SGCZ2450S SAFETY FIRST Instructions contained in warnings within this manual marked with a symbol concern critical points which must be taken into consideration to prevent possible serious bodily injury, and for this reason you are requested to read all such instructions carefully and follow them without fail.
US-3 SGCZ2450S U S 1. Parts location 2. Specifications ■ SGCZ2450S Overall size ( L x W x H ) ····································································76.2 (1935) x 9.1 (230) x 10.
US-4 SGCZ2450S 3. W arning labels on the machine For safe operation and maintenance, symbols are carved in relief on the machine. According to these indications, please be careful not to take a mistake.
US-5 SGCZ2450S U S •A brushcutter or trimmer can be dangerous if used incorrectly or carelessly, and can cause serious or fatal injury to the operater or others. It is extremely important that you read and understand the contents of this Owner's manual.
US-6 SGCZ2450S contain dangerous carbon monoxide. 10. Never to touch the spark plug or plug cord while the engine is in operation Doing so may result in being subjected to an electrical shock.
US-7 SGCZ2450S U S 5. For safe operation ■ Transport 1. Drain the fuel from the fuel tank before transporting or storing the product. 2. When hand-carrying the product, cover over the cutting part, lift up the product and carry it paying attention to the blade.
US-8 SGCZ2450S 5. For safe operation lubricant, always be sure to use only RedMax products or products which have been certified by RedMax for use with the RedMax product.
US-9 SGCZ2450S U S 6. Set up ■ MOUNTING ENGINE (SE1) 1. Install the engine to the driveshaft so that the cylinder head and the stop switch may come on the same side. 2. Using attached four bolts, secure the connection firmly with equal force (Torque: 25in-lbs)(Torque: 2.
US-10 SGCZ2450S lines or fuel tank of the engine. • Failures caused by operating engines on gasoline with octane rating lower than 89 are not covered by the RedMax Two- Stroke engine warranty.
US-11 SGCZ2450S U S 7. Fuel test standard has been discontinued by API in 1995 and it no longer exists. • Gasoline/Oil mixture Storage Recommendations Store your gasoline or gasoline/oil mixture in a cool dry area in a tightly sealed approved container to limit the entry of moisture and additional air (oxygen).
US-12 SGCZ2450S 8. Operation ■ STARTING ENGINE The cutting head will start rotating upon the engine starts. 1. Rest the unit on a flat, firm place. Keep the cutting head off the ground and clear of surrounding objects as it will start rotating upon starting of the engine.
US-13 SGCZ2450S U S 8. Operation OP7 OP8 OP9 OP10 OP11 OP12 OP13 OP14 ■ HOW TO USE • Adjust the front handle to the most comfortable position. • Start the engine and pull the throttle lever gradually. The blades will start moving as the engine speed goes up.
US-14 SGCZ2450S To remove blades: 1. Turn over the machine and remove the bottom cover (MA3-1) by removing the 4 screws. 2. Loosen 4 screws and remove the lower blade (MA3- 2) 3. Loosen 4 screws and remove the upper blade (MA3-3), To install blades: The upper and lower blades are interchangeable.
US-15 SGCZ2450S U S ■ AIR FILTER • The air filter, if clogged, will reduce the engine performance. Check and clean the filter element. If the element is broken or clogged, replace with a new one. (MA4) (1) air filter ■ FUEL FILTER • When the engine runs short of fuel supply, check the fuel cap and the fuel filter for blockage.
US-16 SGCZ2450S 9. Maintenance MA10 (1) (2) MA9 • Aged fuel is one of major causes of engine starting failure. Before storing the unit, empty the fuel tank and run the engine until it uses all the fuel left in the fuel line and the carburetor. Store the unit indoor taking necessary measures for rust prevention.
US-17 SGCZ2450S U S 13. T roubleshooting guide Case 1. Starting failure CHECK PROBABLE CAUSES ACTION fuel tank ➞ incorrect fuel ➞ drain it and with correct fuel fuel filter ➞ fuel filter is clog.
US-18 SGCZ2450S The EPA (U.S. Environmental Protection Agency), CARB (California Air Resources Board), Environment Canada and RedMax are pleased to explain the emissions control system's warranty on your 2009 and later small off-road engine. In U.
US-19 SGCZ2450S U S warranty is warranted for the remaining warranty period. Any warranted part that is scheduled only for regular inspection in the maintenance schedule will be warranted for a period of two years.
An important point after buying a device RedMax SGCZ2450S (or even before the purchase) is to read its user manual. We should do this for several simple reasons:
If you have not bought RedMax SGCZ2450S yet, this is a good time to familiarize yourself with the basic data on the product. First of all view first pages of the manual, you can find above. You should find there the most important technical data RedMax SGCZ2450S - thus you can check whether the hardware meets your expectations. When delving into next pages of the user manual, RedMax SGCZ2450S you will learn all the available features of the product, as well as information on its operation. The information that you get RedMax SGCZ2450S will certainly help you make a decision on the purchase.
If you already are a holder of RedMax SGCZ2450S, but have not read the manual yet, you should do it for the reasons described above. You will learn then if you properly used the available features, and whether you have not made any mistakes, which can shorten the lifetime RedMax SGCZ2450S.
However, one of the most important roles played by the user manual is to help in solving problems with RedMax SGCZ2450S. Almost always you will find there Troubleshooting, which are the most frequently occurring failures and malfunctions of the device RedMax SGCZ2450S along with tips on how to solve them. Even if you fail to solve the problem, the manual will show you a further procedure – contact to the customer service center or the nearest service center
