Instruction/ maintenance manual of the product SBS0507 Powerex
Go to page of 20
Please read and save these instructions. Read carefully before attempting to assemble, install, operate or maintain the product described. Protect yourself and others by observing all safety information. Failure to comply with instructions could result in personal injury and/or prop- erty damage! Retain instructions for future reference.
2 Scroll Air Compr essors T ankmount/Basemount Installation RECEIVING THE UNIT Immediately upon receipt of the scroll compressor, the unit should be inspect- ed for any damage which may have occurred in shipment. Any shipping damage must be immediately filed with the freight carrier.
3 Scroll Air Compr essors T ankmount/Basemount RESET RESET Figure 1 - SBS Scroll Basemount Simplex Figure 2 - STS Scroll Tankmount Figure 3 - STD Scroll Tankmount Duplex Aftercooler Scroll Air End Pre.
RESET 4 Scroll Air Compr essors T ankmount/Basemount SCFM Full Load Gallon Dimension Ship Model HP Phase @100 PSIG Voltage Amperage Tank LxWxH Weight (Lbs.) SBS0307 3 3 8.6 208/230/460 8.7/8.0/4.0 Basemount 29x19x19 160 SBS1307 3 1 8.6 230 17 Basemount 29x19x19 175 SBS0507 5 3 14.
5 Maintenance Schedule Operating Hours Item Action needed 500 2500 5000 10,000 15,000 20,000 Remarks Tank Drain moisture Daily Inlet air filter Replace (Every 2,500 hrs or less) Part #91348550 .
6 Scroll Air Compr essors T ankmount/Basemount Electrical Wiring Diagram - Simplex Figure 4 - 3-5 HP Basemount/Simplex Single-Phase 208/230 Volts Field furnished power supply Disconnect Red Black .
7 Scroll Air Compr essors T ankmount/Basemount Electrical Wiring Diagram - Simplex Figure 5 - 3-5 HP Basemount/Simplex Three-Phase 208-230/460 Volts Disconnect Black Motor Red Pressure electric switch.
8 Scroll Air Compr essors T ankmount/Basemount PANEL DATA - 3 PHASE, 60 Hz OVERLOAD SETTINGS TOTAL PANEL F.L.A. F.L.A. TOTAL UNIT 208 230 460 PANEL 208 230 460 HP VOLT VOLT VOLT HP VOLT VOLT VOLT 3 10.29 9.2 4.6 6 21.1 18.9 9.7 5 15.56 14.0 7.0 10 31.
9 Scroll Air Compr essors T ankmount/Basemount Replacement Parts List for SBS Models RESET RESET RESET Ref. SBS Model No. Description Part Number Qty. 1 Motor 3 HP 3 Phase MC022374AV 1 Motor 3 HP 1 Ph.
10 Scroll Air Compr essors T ankmount/Basemount Replacement Parts List for STS Models Ref. STS Model No. Description Part Number Quantity 1 Motor: 3 HP 3 Phase MC022374AV 1 3 HP 1 Phase MC301519AV 1 5.
11 Scroll Air Compr essors T ankmount/Basemount Replacement Parts List for STD Models Ref. STD Model No. Description Part Number Quantity 1 Motor: 3 HP 3 Phase MC022374AV 1 3 HP 1 Phase MC301519AV 1 5.
Scroll Air Compr essors T ankmount/Basemount Powerex • 150 Production Drive • Harrison, OH 45030 • USA Powerex Limited W arranty Powerex 3 Year / 10,000 Hour Extended Parts Limited Warranty - Po.
The Powerex Oilless Rotary Scroll Air Compressor has advanced scroll com- pressor technology through the devel- opment of a completely oilless unit. The Powerex Scroll Compressor offers a dynamically balanced air end which insures vibration-free operation.
2 Scroll Air Compr essors GREASE DELIVERY SLAE03 SLAE05 Bearing 1st Time 2nd Time 1st Time 2nd Time Orbit Scroll Bearing 5 Times 3 Times 6 Times 4 Times Pin Crank Bearing Orbit Scroll Side 5 Times 3 Times 6 Times 4 Times Pin Crank Bearing Housing Side 5 Times 3 Times 6 Times 4 Times NOTE: Each pump of the grease gun equals 0.
3 Scroll Air Compr essors Figure 4 Figure 5 Extension Adaptor Needle Adaptor Orbit Scroll Bearings Grease Fitting Housing Side Bearings Maintenance Schedule Operating Hours Item Action needed 500 2500.
expensive filtration. The tip seal should be replaced every 10,000 hours of oper- ation. 1. Confirm if the tip seal you pur- chased is correct for the air end you are repairing (See Parts Listing below). 2. Confirm if the following parts are included (See Figure 6).
5 Scroll Air Compr essors Figure 9 Lip Direction Lip Surface (Inside) Enter Side Lip Side (Grooved Bottom) Machined To Avoid Movement During Installation Figure 10 Dust Seal 3 o’clock Position 6 o.
6 Scroll Air Compr essors Figure 12 - Compressor Parts 19 1 2 4 3 6 5 8 7 10 9 12 11 14 15 16 17 18 15 17 A A B B 13.
7 Scroll Air Compr essors Ref. Part No. For Models No. Description SLAE03 SLAE05 SLAE03HP SLAE05HP Quantity 1 Airend Pulley 92805020 IP600400AV 92805020 IP600400AV 1 2 Key IP600600AV IP600600AV IP6006.
Scroll Air Compr essors Powerex • 150 Production Drive • Harrison, OH 45030 • USA Powerex Limited W arranty POWEREX 3 YEAR / 10,000 HOUR EXTENDED PARTS LIMITED WARRANTY - Powerex warrants each C.
An important point after buying a device Powerex SBS0507 (or even before the purchase) is to read its user manual. We should do this for several simple reasons:
If you have not bought Powerex SBS0507 yet, this is a good time to familiarize yourself with the basic data on the product. First of all view first pages of the manual, you can find above. You should find there the most important technical data Powerex SBS0507 - thus you can check whether the hardware meets your expectations. When delving into next pages of the user manual, Powerex SBS0507 you will learn all the available features of the product, as well as information on its operation. The information that you get Powerex SBS0507 will certainly help you make a decision on the purchase.
If you already are a holder of Powerex SBS0507, but have not read the manual yet, you should do it for the reasons described above. You will learn then if you properly used the available features, and whether you have not made any mistakes, which can shorten the lifetime Powerex SBS0507.
However, one of the most important roles played by the user manual is to help in solving problems with Powerex SBS0507. Almost always you will find there Troubleshooting, which are the most frequently occurring failures and malfunctions of the device Powerex SBS0507 along with tips on how to solve them. Even if you fail to solve the problem, the manual will show you a further procedure – contact to the customer service center or the nearest service center
