Instruction/ maintenance manual of the product PO1742STB Poulan
Go to page of 44
MODEL NO . PO1742STB 17.0 HP 42 Inc h La wn T ractor 187189 6.12.03 MH PRINTED IN U .S .A. F or P ar ts and Ser vice, contact our authorized distributor: call 1-800-849-1297 F or T echnical Assistance.
2 • A void star ting or stopping on a slope. If tires lose tr ac- tion, disengage the blades and proceed slo wly straight down the slope . DO NO T: • Do not turn on slopes unless necessar y , and then, turn slowly and gradually downhill, if possib le.
3 W ARNING: In order to prevent ac- ci den tal star ting when setting up, trans por t ing, ad just ing or making re- pairs, al ways dis con nect spark plug wire and place wire where it can not contact spark plug. W ARNING: Do not coast do wn a hill in neutral, you ma y lose control of the tractor .
4 T ABLE OF CONTENTS SAFETY RULES ......................................................... 2-3 PRODUCT SPECIFICA TIONS ....................................... 4 CUST OMER RESPONSIBILITIES ................................. 4 ASSEMBL Y ................
5 CONTENTS OF HARD W ARE P A CK Steering Wheel Seat Keys Slope Sheet (1) Oil Drain Tube (1) Bolt (1) Washer 17/32 x 1-3/16 x 12 Gauge (1) Lock Washer 1/2 (1) Large Flat Washer (1) Hex Bolt 1/4-28 x 1-.
6 ASSEMBL Y T OOLS REQUIRED FOR ASSEMBL Y A sock et wrench set will make assembly easier . Stan dard wrench sizes are listed. (2) 7/16" wrenches Utility knif e (2) 3/4" wrench Tire pres sure.
7 ASSEMBL Y FIG. 2 T O ROLL TRA CT OR OFF SKID (See Op- er a tion section for location and func tion of con trols) • Press lift le ver plunger and raise attachment lift le ver to its highest po si tion. • Release par king brake b y depressing clutch/brake ped al.
8 ASSEMBL Y ✓ CHECKLIST BEFORE Y OU OPERA TE AND ENJO Y Y OUR NEW TRAC- T OR, WE WISH TO ASSURE THA T Y OU RECEIVE THE BEST PER FOR MANCE AND SA TISF ACTION FR OM THIS QU ALITY PROD UCT . PLEASE REVIEW THE FOLLO WING CHECKLIST: ✓ All assembly instructions hav e been completed.
9 OPERA TION These symbols ma y appear on your tractor or in literature supplied with the product. Lear n and understand their mean- ing. DANGER, KEEP HANDS AND FEET AWAY FREE WHEEL (Automatic Models .
10 OPERA TION KNO W Y OUR TRA CT OR READ THIS O WNER'S MANU AL AND SAFETY RULES BEFORE OPERA TING Y OUR TRA CT OR Compare the illustrations with y our tractor to f amiliar ize y ourself with the locations of various controls and ad just ments. Sav e this manual f or future ref erence.
11 NO TE: Under cer tain conditions when tractor is standing idle with the engine running, hot engine exhaust gases ma y cause “brown ing” of grass.
12 T O OPERA TE ON HILLS W ARNING: Do not drive up or do wn hills with slopes great er than 15° and do not drive across an y slope . • Choose the slowest speed bef ore star ting up or down hills. • A void stopping or changing speed on hills. • If slowing is necessary , move throttle control le ver to slower position.
13 OPERA TION T O ST ART ENGINE (See Fig. 5) When star ting the engine for the fi rst time or if the engine has run out of fuel, it will take e xtra cranking time to mov e fuel from the tank to the engine. • Sit on seat in operating position, depress clutch/brak e pedal and set parking brake .
14 MAINTENANCE BEFO RE EAC H USE T R A C T 0 R Inspect Muffler/Spark Arrester Lubrication Chart Check Brake Operation Clean Air Filter Change Engine Oil (with oil filter) Replace Air Filter Paper Cart.
15 MAINTENANCE FIG. 9 FIG. 8 B A TTER Y Y our tractor has a batter y charging system which is suf fi cient f or nor mal use. Howe ver , per iodic charging of the batter y with an automotive charger will e xtend its lif e. • K eep batter y and ter minals clean.
16 MAINTENANCE V- B E LT S Check V -belts for deterioration and wear after 100 hours and replace if necessar y . The belts are not adjustable. Re place belts if they begin to slip from w ear. TRANSAXLE COOLING K eep transaxle free from build-up of dirt and chaff which can restrict cooling.
17 MAINTENANCE CLEANING • Clean engine, batter y , seat, fi nish, etc. of all foreign matter . • Keep fi nished surfaces and wheels free of all gasoline , oil, etc.
18 SER VICE AND ADJUSTMENTS W ARNING: T O A V OID SE RI OUS IN JU R Y , BEFORE PERFORMING ANY SER VICE OR ADJUST - MENTS: • Depress clutc h/brake pedal fully and set parking brake. • Place gearshift lever in neutral (N) position. • Place attachment c lutch in “DISENGAGED” position.
19 T O REPLA CE MO WER BLADE DRIVE BEL T (See Fig. 20) The mower b lade dr iv e belt ma y be replaced without tools. P ar k the tractor on le vel surf ace. Engage parking brake . BEL T REMO V AL - • Remove mo wer from tractor (See “T O REMO VE MO W ER” in this section of this man ual).
20 SER VICE AND ADJUSTMENTS FIG. 20 FIG. 22 T O REPLA CE MO TION DRIVE BEL T (See Fig. 22) P ar k the tractor on le vel surf ace. En gage parking brake . Fo r a s sis tance, there is a belt installation guide decal on bottom side of left f ootrest. BEL T REMO V AL - • Remov e mower (See “TO RE MO VE MOWER” in this section of manual).
21 ADJUSTMENT BOL T NEUTRAL LOCK GA TE GEARSHIFT LEVER FIG. 23 SER VICE AND ADJUSTMENTS T O ADJUST STEERING WHEEL ALIGN- MENT If steering wheel crossbars are not hor izontal (left to right) when wheels are positioned straight f orward, remov e steer- ing wheel and reassemble per instructions in the Assembly section of this manual.
22 SER VICE AND ADJUSTMENTS T O REPLA CE HEADLIGHT BULB • Raise hood. • Pull bulb holder out of the hole in the bac kside of the grill. • Replace b ulb in holder and push bulb holder securely back into the hole in the bac kside of the grill. • Close hood.
23 ST ORA GE Immediately prepare your tr actor f or storage at the end of the season or if the tractor will not be used f or 30 days or more. W ARNING: Ne ver store the trac tor with gas o line in the tank inside a building where fumes may reac h an open fl ame or spark.
24 TR OUBLESHOO TING POINTS Will not start 1. Out of fuel. 1. Fill fuel tank. 2. Engine not “CHOKED” properly . 2. See “TO ST ART ENGINE” in Operation section. 3. Engine fl ooded. 3. Wait se veral minutes bef ore attempting to star t. 4. Bad spark plug.
25 TR OUBLESHOO TING POINTS PROBLEM CA USE CORRECTION Engine continues to run 1. F aulty operator-safe ty presence control system. 1. Check wiring, switches and connections. If not when operator leaves seat corrected, contact an authorized service center/ with attachment clutc h department.
26 SER VICE NO TES.
27 REP AIR P ARTS TRA CT OR - - MODEL NUMBER PO1742STB SCHEMA TIC BATTERY FUSE IGNITION SWITCH RED RED RED BLACK IGNITION UNIT HEADLIGHTS REMOVABLE CONNECTIONS BLACK BLACK BLACK WHITE WHITE WHITE RED .
28 REP AIR P ARTS TRA CT OR - - MODEL NUMBER PO1742STB ELECTRICAL 28 29 26 24 42 43 27 27 25 41 27 27 40 33 90 30 8 2 1 27 16 16 52 48 22 21.
29 REP AIR P ARTS TRA CT OR - - MODEL NUMBER PO1742STB ELECTRICAL 1 163465 Batter y 12 V olt 25 Amp 2 74760412 Bolt Hex Hd 1/4-20unc X 3/4 8 176689 Box Battery 16 176138 Switch Interlock Push -In 21 1.
30 REP AIR P ARTS TRA CT OR - - MODEL NUMBER PO1742STB CHASSIS AND ENCLOSURES 26 25 58 64 208 13 208 11 1 209 2 9 208 209 209 209 5 5 207 209 142 209 142 17 29 28 12 51 57 53 52 54 55 145 37 209 37 24 26 25 31 24 30 35 209 26 33 10 26 34 35 18 14 38 14 206 212 chassis-pl.
31 REP AIR P ARTS TRA CT OR - - MODEL NUMBER PO1742STB CHASSIS AND ENCLOSURES 1 174619 Chassis 2 176554 Drawbar 3 17000612 Screw 3/8-16 x .75 5 155272 Bumper Hood/Dash 9 168336X010 Dash P/L 10 7214060.
32 REP AIR P ARTS TRA CT OR - - MODEL NUMBER PO1742STB DRIVE 29 28 112 14 41 38 39 89 57 69 51 74 75 78 76 77 1 25 19 24 26 2 53 35 34 37 36 35 62 36 64 65 59 56 212 55 63 116 70 77 61 22 27 26 85 52 .
33 REP AIR P ARTS TRA CT OR - - MODEL NUMBER PO1742STB DRIVE KEY P ART NO . NO . DESCRIPTION KEY P ART NO . NO . DESCRIPTION 1 - - - - - - T ransaxle P eerless (206-545C) (Order par ts from transaxle .
34 REP AIR P ARTS TRA CT OR - - MODEL NUMBER PO1742STB STEERING ASSEMBL Y 44 51 54 5 9 5 7 7 9 4 3 32 43 6 43 8 10 40 11 8 6 9 46 46 8 6 9 2 47 47 26 30 28 1 41 42 37 36 37 38 12 39 68 67 67 67 13 65 85 85 68 15 15 15 29 29 82 88 71 17 29 43 91 steering_pl.
35 REP AIR P ARTS TRA CT OR - - MODEL NUMBER PO1742STB STEERING ASSEMBL Y 1 140044X428 Wheel Steering Auto Blac k 2 175131 Axle Asm F ront 3 169840 Spindle Asm Lh 4 169839 Spindle Asm Rh 5 6266H Beari.
36 REP AIR P ARTS TRA CT OR - - MODEL NUMBER PO1742STB ENGINE 2 1 OPTIONAL EQUIPMENT Spark Arrester 29 44 46 32 31 33 37 33 13 4 72 78 81 3 16 78 23 45 14 38 40 engine-bs.
37 REP AIR P ARTS TRA CT OR - - MODEL NUMBER PO1742STB SEA T ASSEMBL Y KEY P ART NO . NO . DESCRIPTION KEY P ART NO . NO . DESCRIPTION 14 72050412 Bolt Rdhd Sht Nk 1/4-20 x 1-1/2 15 134300 Spacer Spli.
38 5 11 16 6 9 2 3 10 2 8 14 WHEELS & TIRES KEY P ART NO . NO . DESCRIPTION 1 59192 Cap V alv e Tire 2 65139 Stem V alv e 3 106222X Tire F Ts 15 X 6 0 - 6 Ser vice 4 59904 T ube F ront (Ser vice I.
39 REP AIR P ARTS TRA CT OR - - MODEL NUMBER PO1742STB MO WER LIFT 15 20 16 17 18 20 20 15 20 4 5 6 2 3 1 6 5 4 7 8 12 11 31 32 31 32 19 19 13 13 13 13 lift-rh.1piece_3 1 159460 Wire Asm Inner/Sprg w/Plunger 2 159471 Shaft Asm Lift 3 105767X Pin Groov e 4 12000002 E Ring #5133-62 5 19211621 W asher 21/32 x 1 x 21 Ga.
40 REP AIR P ARTS TRA CT OR - - MODEL NUMBER PO1742STB MO WER DECK 15 14 13 11 10 9 8 16 68 37 184 30 31 32 33 146 148 145 150 45 144 147 147 142 149 142 54 52 53 55 56 34 1 46 44 21 24 25 26 27 2 28 .
41 REP AIR P ARTS TRA CT OR - - MODEL NUMBER PO1742STB MO WER DECK 1 165892 Mower Dec k Assembly , 42" 2 72140506 Bolt 3 138017 Brack et Asm F r .
42 LIMITED W ARRANTY The Manuf acturer warrants to the original consumer purchaser that this product as manufactured is free from def ects in materi- als and work man ship .
43 T E C U M S E H ® Issued Jan uar y 1980 Re vised Jan uar y 1991 T E C U M S E H ® SERVICE POLICY POLICY W ARRANTY LIMITED W ARRANTIES FOR NEW PEERLESS GEAR PO WER TRAIN COMPONENTS A.
15 DEGREES MAX. FOLD ALONG DOTTED LINE THIS IS A 15 DEGREE SLOPE ONLY RIDE UP AND DOWN HILL, NOT ACROSS HILL SUGGESTED GUIDE FOR SIGHTING SLOPES FOR SAFE OPERATION WARNING: To avoid serious injury, operate your tractor up and down the face of slopes, never across the face.
An important point after buying a device Poulan PO1742STB (or even before the purchase) is to read its user manual. We should do this for several simple reasons:
If you have not bought Poulan PO1742STB yet, this is a good time to familiarize yourself with the basic data on the product. First of all view first pages of the manual, you can find above. You should find there the most important technical data Poulan PO1742STB - thus you can check whether the hardware meets your expectations. When delving into next pages of the user manual, Poulan PO1742STB you will learn all the available features of the product, as well as information on its operation. The information that you get Poulan PO1742STB will certainly help you make a decision on the purchase.
If you already are a holder of Poulan PO1742STB, but have not read the manual yet, you should do it for the reasons described above. You will learn then if you properly used the available features, and whether you have not made any mistakes, which can shorten the lifetime Poulan PO1742STB.
However, one of the most important roles played by the user manual is to help in solving problems with Poulan PO1742STB. Almost always you will find there Troubleshooting, which are the most frequently occurring failures and malfunctions of the device Poulan PO1742STB along with tips on how to solve them. Even if you fail to solve the problem, the manual will show you a further procedure – contact to the customer service center or the nearest service center
