Instruction/ maintenance manual of the product 2000 Series Pentair
Go to page of 11
Rev . C 7-6-01 1 P/N 075122.
P/N 075122 2 Rev . C 7-6-01 * By Weight - 1 lb. of D.E. per 10 sq. ft. of filter surface area. Filter Model *By Weight Number Pounds 1018 1. 8 1027 2. 7 1036 3. 6 1045 4. 5 1054 5. 4 2024 2. 4 2036 3. 6 2048 4. 8 2060 6. 0 2072 7. 2 Diatomaceous Earth (D.
Rev . C 7-6-01 3 P/N 075122 SECTION II. FILTER INSTALLATION. A . GENERAL INFORMATION 1 . New pools have a tremendous amount of debris due to dirt in the lines, plaster dust, etc. This debris will be removed by the filter and will require daily backwashing of the filter until it is removed.
P/N 075122 4 Rev . C 7-6-01 10. Provide space and lighting for routine maintenance access. Do not mount electrical controls over filter. Install electrical controls (e.g., on/off switches, timers, control systems, etc.) at least five (5) feet from the filter.
Rev . C 7-6-01 5 P/N 075122 D . HOW TO CLEAN THE SEPARATION TANK , performed after each backwash operation. (If installed or if applicable.) The purpose of the separation tank is to collect the spent diatomaceous earth during backwashing (cleaning) of the filter.
P/N 075122 6 Rev . C 7-6-01 7 . Use garden hose to rinse down filter elements until all debris has been flushed from tank. Then screw drain plug on backwash line on models with Separation Tank. 8 . Unscrew wing nut; remove washer and unclip air vent tube from holding wheel.
Rev . C 7-6-01 7 P/N 075122 SECTION III. TECHNICAL DATA A . REPLACEMENT PARTS 1. Model SM 1000 & 2000 Filter 1 2 4 3.
P/N 075122 8 Rev . C 7-6-01 A . REPLACEMENT PARTS, contd. 3. Rotary Valve Model SMBW w/Noryl Rotor.
Rev . C 7-6-01 9 P/N 075122 SECTION IV. MAINTENANCE-TROUBLE SHOOTING A . Before performing any of the recommended actions below, it is important to consult the instruction manual including all warnings. S M O T P M Y SR O F K O O L O T T A H WN O I T C A D E D N E M M O C E R l o o P o T ) .
P/N 075122 10 Rev . C 7-6-01 SECTION V. HOW TO USE THE FILTER LID OPENER TOOL 1. T urn pump off. 2. Open the air relief valve. (See Figure 1.) and wait for thank water to drain into pool. 3. Remove the clamp ring. 4. Insert the filter lid opener as shown in Figure 2.
Rev . C 7-6-01 11 P/N 075122 SM SERIES FIL TER LIMITED W ARRANTY Filter Serial No. Y our SM Series filter is a quality product of Pentair Pool Products which warrants that it is fit for the ordinary p.
An important point after buying a device Pentair 2000 Series (or even before the purchase) is to read its user manual. We should do this for several simple reasons:
If you have not bought Pentair 2000 Series yet, this is a good time to familiarize yourself with the basic data on the product. First of all view first pages of the manual, you can find above. You should find there the most important technical data Pentair 2000 Series - thus you can check whether the hardware meets your expectations. When delving into next pages of the user manual, Pentair 2000 Series you will learn all the available features of the product, as well as information on its operation. The information that you get Pentair 2000 Series will certainly help you make a decision on the purchase.
If you already are a holder of Pentair 2000 Series, but have not read the manual yet, you should do it for the reasons described above. You will learn then if you properly used the available features, and whether you have not made any mistakes, which can shorten the lifetime Pentair 2000 Series.
However, one of the most important roles played by the user manual is to help in solving problems with Pentair 2000 Series. Almost always you will find there Troubleshooting, which are the most frequently occurring failures and malfunctions of the device Pentair 2000 Series along with tips on how to solve them. Even if you fail to solve the problem, the manual will show you a further procedure – contact to the customer service center or the nearest service center
