Instruction/ maintenance manual of the product CSS610RSB Napoleon Grills
Go to page of 24
RET AIN THIS MANUAL FOR FUTURE REFERENCE GARDER CE LIVRE POUR RÉFÉRENCES FUTURES CSS610RSB N415-0126 / A PR 1 1/ 05 SERIAL / SÉRIE#______________________ GOURMET GRILLS (PG 2-10) LE GRILS DU GOURMET (PG 11-19) MANUF ACTURED FOR / MANUF ACTURE POUR : NAPOLEON APPLIANCE CORP .
2 CONDITIONS AND LIMIT A TIONS NAPOLEON GAS GRILL CONTINENT AL LIMITED LIFETIME W ARRANTY NAPOLEON gas grills are manufactured under the strict Standard of the world recognized ISO 9001-2000 Quality Assurance Certificate.
3 Do not try to light this appliance without reading "LIGHTING" instructions section of this manual. FOR YOUR SAFETY DO NOT STORE OR USE GASOLINE OR OTHER FLAMMABLE V APOURS AND LIQUIDS IN THE VICINITY OF THIS OR ANY OTHER APPLIANCE. AN LP CYLINDER NOT CONNECTED FOR USE MUST NOT BE STORED IN THE VICINITY OF THIS OR ANY OTHER APPLIANCE.
4 DO'S DON'TS • Read the entire instruction manual before operating the gas grill. • Maintain proper clearance to combustibles (10" to rear and sides). Additional clearance is recommended near vinyl siding or large panes of glass. • Leak test the unit before initial use, annually and whenever any gas components are replaced.
5 DO NOT USE A FLAME T O LEAK TEST . LEAK TESTING: Although all gas connections on your gas grill are thoroughly leak tested at the factory , a leak test must be done before initial use, annually and whenever any gas components are replaced or serviced.
6 Open lid. Main Burner Lighting Push in on any main burner knob and turn to “HI”. A click should be heard from the valve, sending a spark to light the pilot flame. If ignition is not immediate, turn burner control off. Wait 5 minutes. Ensuring all burner controls are in the off position, slowly turn on the gas supply valve.
7 When lit for the first time, the gas grill will emit a slight odour . This is a normal temporary condition caused by the "burn-in" of the lubricants used in the manufacturing process and will not occur again. Simply run the main burners on high for approximately ½ hour with the lid closed.
8 BURNER - The burner is made from heavy wall 304 stainless steel, but due to the extreme heat and corrosive environment, surface corrosion will occur . Use a brass wire brush to remove surface corrosion. Clean any blocked ports using an opened paper clip.
9 Problem Possible Causes Solution Low heat / Low flame when valve turned to high. For propane - improper lighting procedure. Ensure lighting procedure is followed carefully . All gas grill valves must be in the off position when the tank valve is turned on.
10 Before contacting the customer service department, check the NAC web site for more extensive cleaning, maintenance, troubleshooting and part replacement instructions at www .napoleongrills.com. Contact the factory directly for replacement part s and warranty claims.
11 LE GRILS DU GOURMET R GARANTIE À VIE LIMITÉE DU CONTINENT AL CONDITIONS ET LIMIT A TIONS “NAPOLÉON garantit ses produits contre tous défauts de fabrication à l’acheteur d’origine seulement (i.
12 Ne tentez pas d’allumer cet appareil avant d’avoir lu la section “INSTRUCTIONS D’ALLUMAGE” de ce manuel. POUR VOTRE SÉCURITÉ N’ENTREPOSEZ P AS ET N’UTILISEZ P AS D’ESSENCE OU AUTRES LIQUIDES ET V APEURS INFLAMMABLES À PROXIMITÉ DE CET OU TOUT AUTRE APP AREIL.
13 QUOI F AIRE ET NE P AS F AIRE INFORMA TION GÉNÉRALE CE GRIL À GAZ EST CERTIFIÉ SELON LES NORMES NA TIONALES CANADIENNES ET AMÉRICAINES, CAN/CGA-1.6-M95 ET AINSI Z21.58 - 1995 RESPECTIVEMENT POUR DES GRILS À GAZ POUR L ’EXTÉRIEUR ET SON INST ALLA TION DEVRAIT ÊTRE CONFORME AUX CODES LOCAUX.
14 INSTRUCTIONS DE BRANCHEMENT DU GAZ TEST DE DÉTECTION DE FUITES RACCORD DE LA BONBONNE: Assurez-vous que le tuyau du régulateur de gaz est sans anomalie. Enlevez les bouchons sur la soupape de gaz à la bonbonne. Connectez le régulateur QCC1 sur la soupape de gaz QCC1.
15 Appuyez sur l’un des boutons de contrôle de brûleurs principal et tournez-le à “HI”. V ous devez entendre un clic de la soupape, envoyant une étincelle pour allumer la flamme de la veilleuse.
16 INSTRUCTIONS D’OPÉRA TION NETT OY AGE Lorsqu’il est allumé pour la première fois, le gril dégagera une légère odeur . Ceci est un phénomène normal et temporaire causé par l’évaporation des peintures et lubrifiants internes utilisés dans le processus de fabrication et ne se reproduira pas.
17 INSTRUCTIONS D’ENTRETIEN BLEUE FONCÉE BLEUE PÂLE BRÛLEUR ORIFICE DU BRÛLEUR POINTE JAUNE 1/2" Fermez le gaz à la source et débranchez l’appareil avant l’entretien. L ’entretien devrait être effectué seulement lorsque le gril est froid pour éviter toutes possibilités de brûlure.
18 GUIDE DE DÉP ANNAGE Problème Causes Probables Solution Pour le propane - procédure d’allumage incorrect. Assurez-vous que la procédure d’allumage est suivie à la lettre.
19 COMMANDE DES PIÈCES DE RECHANGE Avant de contacter le bureau de service du clientele, veuillez prendre note, que notre guide de dépanage est maintenent dispoible sur le net a www .napoleongrills.com. Ici, vous trouver beaucoup d'information comme les instructions de d'opération et de nettoyage et comment remplacer les pièces.
20 1. ST AINLESS STEEL P ARTS MA Y HA VE A PROTECTIVE PLASTIC COA TING , REQUIRED FOR THE MANUF ACTURING PROCESS. PLEASE REMOVE THIS COA TING BEFORE OPERA TING THE UNIT . LES PIÈCES EN ACIER INOXYDABLE PEUVENT ÊTRE RECOUVERTES D'UNE PELLICULE DE PROTECTION, NÉCESSAIRE DURANT LE PROCÉDÉ DE F ABRICA TION.
21 2..
22 3. 4..
23 x - standard p - propane units only p - appareils propane seulement x - compris n - natural gas units only n - appareils gaz naturel seulement I TEM # PA RT # DESCR IP T IO N 1 n010- 0457 li d / c .
24 5..
An important point after buying a device Napoleon Grills CSS610RSB (or even before the purchase) is to read its user manual. We should do this for several simple reasons:
If you have not bought Napoleon Grills CSS610RSB yet, this is a good time to familiarize yourself with the basic data on the product. First of all view first pages of the manual, you can find above. You should find there the most important technical data Napoleon Grills CSS610RSB - thus you can check whether the hardware meets your expectations. When delving into next pages of the user manual, Napoleon Grills CSS610RSB you will learn all the available features of the product, as well as information on its operation. The information that you get Napoleon Grills CSS610RSB will certainly help you make a decision on the purchase.
If you already are a holder of Napoleon Grills CSS610RSB, but have not read the manual yet, you should do it for the reasons described above. You will learn then if you properly used the available features, and whether you have not made any mistakes, which can shorten the lifetime Napoleon Grills CSS610RSB.
However, one of the most important roles played by the user manual is to help in solving problems with Napoleon Grills CSS610RSB. Almost always you will find there Troubleshooting, which are the most frequently occurring failures and malfunctions of the device Napoleon Grills CSS610RSB along with tips on how to solve them. Even if you fail to solve the problem, the manual will show you a further procedure – contact to the customer service center or the nearest service center
