Instruction/ maintenance manual of the product DCA-125USJ Multiquip
Go to page of 86
P AR TS AND OPERA TION MANUAL OPERA TION AND P AR TS MANUAL P ARTS LIST NO . M3870400004 Re vision #0 (03/11/05) THIS MANU AL MUST A CCOMP ANY THE EQUIPMENT A T ALL TIMES.
P A GE 2 — DCA-125USJ (50 HZ) — OPERA TION AND P AR TS MANU AL — REV . #0 (03/11/05).
DCA-125USJ (50 HZ) — OPERATION AND PARTS MANUAL — REV. #0 (03/11/05) — PAGE 3 1 © COPYRIGHT 2005, MUL TIQUIP INC. MQ P ower Inc , Ultra-Silent series, and the MQ P ower logo are registered tr ademar ks of Multiquip Inc. and ma y not be used, reproduced, or altered without written per mission.
P A GE 4 — DCA-125USJ (50 HZ) — OPERA TION AND P AR TS MANU AL — REV . #0 (03/11/05) T ABLE OF CONTENTS COMPONENT DRA COMPONENT DRA COMPONENT DRA COMPONENT DRA COMPONENT DRA WINGS WINGS WINGS WINGS WINGS Generator Assembly ......................
DCA-125USJ (50 HZ) — OPERATION AND PARTS MANUAL — REV. #0 (03/11/05) — PAGE 5 1 MQ PO WER A Division of Multiquip Inc. POST OFFICE BO X 6254 CARSON, CA 90749 310-537-3700 • 800-421-1244 F AX: 310-632-2656 E-MAIL: mqpower@multiquip.com INTERNET: www .
P A GE 6 — DCA-125USJ (50 HZ) — OPERA TION AND P AR TS MANU AL — REV . #0 (03/11/05) DCA-125USJ (50 HZ)— SPECIFICA TIONS s n o i t a c i f i c e p S r o t a r e n e G .
DCA-125USJ (50 HZ) — OPERATION AND PARTS MANUAL — REV. #0 (03/11/05) — PAGE 7 1 DCA-125USJ (50 HZ)— DIMENSIONS (T OP , SIDE AND FRONT) Figure 1.
P A GE 8 — DCA-125USJ (50 HZ) — OPERA TION AND P AR TS MANU AL — REV . #0 (03/11/05) This Owner's Manual has been developed to provide complete instructions for the safe and efficient operation of the MQ P ow er Model DCA-125USJ (50 HZ)UL TRA-SILENT™ GENERA T OR.
DCA-125USJ (50 HZ) — OPERATION AND PARTS MANUAL — REV. #0 (03/11/05) — PAGE 9 1 Accidental Starting AL W A YS place the engine ON/OFF switch in the OFF position, when the trowel is not in use. Over Speed Conditions NEVER tamper with the factory settings of the engine gov er nor or settings.
P A GE 10 — DCA-125USJ (50 HZ) — OPERA TION AND P AR TS MANU AL — REV . #0 (03/11/05) DCA-125USJ (50 HZ) — R ULES FOR SAFE OPERA TION CAUTION CAUTION CAUTION CAUTION CAUTION : F ailure to f ol.
DCA-125USJ (50 HZ) — OPERATION AND PARTS MANUAL — REV. #0 (03/11/05) — PAGE 11 1 DCA-125USJ (50 HZ) — R ULES FOR SAFE OPERA TION ■ Backfeed to a utility system can cause electrocution and or proper ty damage.
P A GE 12 — DCA-125USJ (50 HZ) — OPERA TION AND P AR TS MANU AL — REV . #0 (03/11/05) DCA-125USJ (50 HZ)— R ULES FOR SAFE OPERA TION ■ NEVER run engine without air filter . Se v ere engine damage ma y occur . ■ AL W A YS ser vice air cleaner frequently to prev ent engine malfunction.
DCA-125USJ (50 HZ) — OPERATION AND PARTS MANUAL — REV. #0 (03/11/05) — PAGE 13 1 Emergencies ■ AL W A Y S know the location of the nearest fire extinguisher . ■ AL W A YS know the location of the nearest and first aid kit . ■ In emergencies always know the location of the nearest phone or keep a phone on the job site .
P A GE 14 — DCA-125USJ (50 HZ) — OPERA TION AND P AR TS MANU AL — REV . #0 (03/11/05) Figure 2. T ypical Generator Grounding Application DCA-125USJ (50 HZ)— INST ALLA TION.
DCA-125USJ (50 HZ) — OPERATION AND PARTS MANUAL — REV. #0 (03/11/05) — PAGE 15 1 Outdoor Installation Install the generator in a area that is free of debris, bystanders, and overhead obstructions. Make sure the generator is on secure level ground so that it cannot slide or shift around.
P A GE 16 — DCA-125USJ (50 HZ) — OPERA TION AND P AR TS MANU AL — REV . #0 (03/11/05) T o reduce the possibility of an accident while transpor ting the generator on public roads, always make sure the trailer (Figure 4) that suppor ts the generator and the towing v ehicle are in good operating condition and both units are mechanically sound.
DCA-125USJ (50 HZ) — OPERATION AND PARTS MANUAL — REV. #0 (03/11/05) — PAGE 17 1 Explanation of Chart: This section is to provide the user with trailer service and maintenance inf or mation. The ser vice and maintenance guidelines referenced in this section apply a wide range of trailers.
P A GE 18 — DCA-125USJ (50 HZ) — OPERA TION AND P AR TS MANU AL — REV . #0 (03/11/05) The DCA-125USJ (50 HZ)generator is equipped with a n umber of safety decals (Figure 4). These decals are provided f or operator saf ety and maintenance information.
DCA-125USJ (50 HZ) — OPERATION AND PARTS MANUAL — REV. #0 (03/11/05) — PAGE 19 1 DCA-125USJ (50 HZ)— GENERA T OR DECALS Figure 4. Generator Decals (Cont.
P A GE 20 — DCA-125USJ (50 HZ) — OPERA TION AND P AR TS MANU AL — REV . #0 (03/11/05) DCA-125USJ (50 HZ)— GENERAL INFORMA TION DCA-125USJ (50 HZ) Series Familiarization Generator The MQ P ow e.
DCA-125USJ (50 HZ) — OPERATION AND PARTS MANUAL — REV. #0 (03/11/05) — PAGE 21 1 DCA-125USJ (50 HZ)— MAJOR COMPONENTS Figure 5. Major Components 3 e l b a T.
P A GE 22 — DCA-125USJ (50 HZ) — OPERA TION AND P AR TS MANU AL — REV . #0 (03/11/05) NO TE P A GE.
DCA-125USJ (50 HZ) — OPERATION AND PARTS MANUAL — REV. #0 (03/11/05) — PAGE 23 1 DCA-125USJ (50 HZ)— GENERA T OR CONTROL P ANEL The definitions below describe the controls and functions of the DCA-125USJ (50 HZ)Generator Control Panel (Figure 6).
P A GE 24 — DCA-125USJ (50 HZ) — OPERA TION AND P AR TS MANU AL — REV . #0 (03/11/05) Figure 7. Engine Operating Panel DCA-125USJ (50 HZ)— ENGINE OPERA TING P ANEL.
DCA-125USJ (50 HZ) — OPERATION AND PARTS MANUAL — REV. #0 (03/11/05) — PAGE 25 1 DCA-125USJ (50 HZ)— ENGINE OPERA TING P ANEL The definitions below describe the controls and functions of the DCA-125USJ (50 HZ)Engine Operating Panel (Figure 7).
P A GE 26 — DCA-125USJ (50 HZ) — OPERA TION AND P AR TS MANU AL — REV . #0 (03/11/05) Output T erminal Familiarization The “ Output T erminal P anel ” (Figure 8) is provided with the followi.
DCA-125USJ (50 HZ) — OPERATION AND PARTS MANUAL — REV. #0 (03/11/05) — PAGE 27 1 100 V AC GFCI Receptac les There are two 100 V AC , 20 amp GFCI (Duplex Nema 5-20R) recepacles provided on the output terminal panel. These receptacles can be accessed in any voltage selector switch position.
P A GE 28 — DCA-125USJ (50 HZ) — OPERA TION AND P AR TS MANU AL — REV . #0 (03/11/05) Figure 13. Connecting Loads Connecting Loads Loads can be connected to the generator by the Ouput T erminal Lugs or the convienience receptacles. (See Figure 13).
DCA-125USJ (50 HZ) — OPERATION AND PARTS MANUAL — REV. #0 (03/11/05) — PAGE 29 1 DCA-125USJ (50 HZ)— LO AD APPLICA TION Single Phase Load Always be sure to check the nameplate on the generator.
P A GE 30 — DCA-125USJ (50 HZ) — OPERA TION AND P AR TS MANU AL — REV . #0 (03/11/05) V oltage Selector Switch The voltage selector switch (Figure 16) is located above the output ter minal panel’ s Har d Wire Hook-up Panel . I t has been provided for ease of voltage selection.
DCA-125USJ (50 HZ) — OPERATION AND PARTS MANUAL — REV. #0 (03/11/05) — PAGE 31 1 DCA-125USJ (50 HZ)— GA UGE READING How to Read the Output T erminal Gauges. The gauges and selector switches on the control panel DO NO T eff ect the generator output.
P A GE 32 — DCA-125USJ (50 HZ) — OPERA TION AND P AR TS MANU AL — REV . #0 (03/11/05) Figure 22. V oltag e Selector Switch 240/139V Three-Phase P osition DCA-125USJ (50 HZ)— OUTPUT TERMINAL P ANEL CONNECTIONS UVWO T erminal Output V oltages V arious output voltages can be obtained using the Output T erminal Lugs .
DCA-125USJ (50 HZ) — OPERATION AND PARTS MANUAL — REV. #0 (03/11/05) — PAGE 33 1 Figure 27. V oltag e Selector Switch 480/277V Three-Phase P osition 3Ø 440/254 Output T erminal Lug V oltages 1. Place the voltage selector switch in the 3Ø 480/277 position as shown in Figure 27.
P A GE 34 — DCA-125USJ (50 HZ) — OPERA TION AND P AR TS MANU AL — REV . #0 (03/11/05) DCA-125USJ (50 HZ)— PRE-SETUP Figure 31. Engine Oil Dipstick When checking the engine oil, be sure to check if the oil is clean.
DCA-125USJ (50 HZ) — OPERATION AND PARTS MANUAL — REV. #0 (03/11/05) — PAGE 35 1 DCA-125USJ (50 HZ)— PRE-SETUP Refueling Procedure: 1. Level T anks – make sure fuel cells are le v el with the ground. F ailure to do so will cause fuel to spill from the tank before reaching full capacity (Figure 33).
P A GE 36 — DCA-125USJ (50 HZ) — OPERA TION AND P AR TS MANU AL — REV . #0 (03/11/05) Coolant (John Deere Antifreez e/Summer Coolant/W ater) John Deere recommends John Deere Antifreeze/Summer Coolant for use in thier engines, which can be purchased in concentrate (and mixed with 50% demineralized water) or pre-diluted.
DCA-125USJ (50 HZ) — OPERATION AND PARTS MANUAL — REV. #0 (03/11/05) — PAGE 37 1 DCA-125USJ (50 HZ)— PRE-SETUP When connecting battery do the following: 1. NEVER connect the battery cables to the battery terminals when the MPEC Control Switch is in either the MANU AL position.
P A GE 38 — DCA-125USJ (50 HZ) — OPERA TION AND P AR TS MANU AL — REV . #0 (03/11/05) DCA-125USJ (50 HZ)— GENERA T OR ST ART -UP PR OCEDURE (MANU AL) WARNING: WARNING: WARNING: WARNING: WARNING: The engine's exhaust contains harmful emissions.
DCA-125USJ (50 HZ) — OPERATION AND PARTS MANUAL — REV. #0 (03/11/05) — PAGE 39 1 DCA-125USJ (50 HZ)— GENERA T OR ST ART -UP PR OCEDURE (MANU AL) Figure 47. V oltage Adjust Control Knob Figure 48. Ammeter (No Load) 1 1 . The ammeter (Figure 48) will indicate zero amps with no load applied.
P A GE 40 — DCA-125USJ (50 HZ) — OPERA TION AND P AR TS MANU AL — REV . #0 (03/11/05) Figure 51. Engine T achometer Gauge 14 . The tachometer gauge (Figure 51) will indicate the speed of the engine when the generator is operating. Under normal operating conditions this speed is appro ximately 1500 RPM’ s.
DCA-125USJ (50 HZ) — OPERATION AND PARTS MANUAL — REV. #0 (03/11/05) — PAGE 41 1 DCA-125USJ (50 HZ)— GENERA T OR ST ART -UP PR OCEDURE (A UT O MODE) 1 . P erf or m steps 1 through 5 in the Bef ore Star ting section as outlined in the Manual Starting Procedure .
P A GE 42 — DCA-125USJ (50 HZ) — OPERA TION AND P AR TS MANU AL — REV . #0 (03/11/05) Shutdown Procedure T o shutdown the gener ator use the f ollowing procedure: 1. Place both the MAIN , GFCI and LO AD circuit break ers as shown in Figure 39 to the OFF position.
DCA-125USJ (50 HZ) — OPERATION AND PARTS MANUAL — REV. #0 (03/11/05) — PAGE 43 1 DCA-125USJ (50 HZ)— MAINTENANCE Service Daily If the engine is operating in very dusty or dry grass conditions, a clogged air cleaner will result. This can lead to a loss of po wer , excessive carbon buildup in the combustion chamber and high fuel consumption.
P A GE 44 — DCA-125USJ (50 HZ) — OPERA TION AND P AR TS MANU AL — REV . #0 (03/11/05) DCA-125USJ (50 HZ)— MAINTENANCE Generator Storage For longe term storage of the generator the following is recommended: z Fill the fuel tank completely . T reat with a fuel stabilizer if necessar y .
DCA-125USJ (50 HZ) — OPERATION AND PARTS MANUAL — REV. #0 (03/11/05) — PAGE 45 1 NO TE P A GE.
P A GE 46 — DCA-125USJ (50 HZ) — OPERA TION AND P AR TS MANU AL — REV . #0 (03/11/05) DCA-125USJ (50 HZ)— TRAILER BRAKES MAINTENANCE Hydraulic Surge Brakes Hydraulic surge brakes (Figure 56) should not require any special attention with the exception of routine maintenance such as shoe and lining replacement.
DCA-125USJ (50 HZ) — OPERATION AND PARTS MANUAL — REV. #0 (03/11/05) — PAGE 47 1 Tires/Wheels/Lug Nuts Tires and wheels are a very impor tant and critical components of the trailer . When specifying or replacing the trailer wheels it is impor tant the wheels, tires , and axle are properly matched.
P A GE 48 — DCA-125USJ (50 HZ) — OPERA TION AND P AR TS MANU AL — REV . #0 (03/11/05) Lug Nut T orque Requirements It is e xtremely impor tant to apply and maintain proper wheel mounting torque on the trailer . Be sure to use only the fasteners matched to the cone angle of the wheel.
DCA-125USJ (50 HZ) — OPERATION AND PARTS MANUAL — REV. #0 (03/11/05) — PAGE 49 1 DCA-125USJ (50 HZ)— TRAILER WIRING DIA GRAM Figure 59. T railer/T owing V ehicle Wiring Diagram.
P A GE 50 — DCA-125USJ (50 HZ) — OPERA TION AND P AR TS MANU AL — REV . #0 (03/11/05) DCA-125USJ (50 HZ)— GENERA T OR WIRING DIA GRAM Figure 60.
DCA-125USJ (50 HZ) — OPERATION AND PARTS MANUAL — REV. #0 (03/11/05) — PAGE 51 1 DCA-125USJ (50 HZ)— ENGINE WIRING DIA GRAM Figure 61. Engine Wiring Diagram.
P A GE 52 — DCA-125USJ (50 HZ) — OPERA TION AND P AR TS MANU AL — REV . #0 (03/11/05) Practically all breakdowns can be prevented by proper handling and maintenance inspections, but in the event of a breakdown, use T able 16 sho wn below f or diagnosis of the Generator .
DCA-125USJ (50 HZ) — OPERATION AND PARTS MANUAL — REV. #0 (03/11/05) — PAGE 53 1 DCA-125USJ (50 HZ)— TR OUBLESHOO TING (ENGINE CONTROLLER) Practically all breakdowns can be prevented by proper.
P A GE 54 — DCA-125USJ (50 HZ) — OPERA TION AND P AR TS MANU AL — REV . #0 (03/11/05) EXPLANA TION OF CODE IN REMARKS COLUMN How to read the marks and remarks used in this parts book. Items Found In the “Remarks” Column Serial Numbers-Where indicated, this indicates a serial number range (inclusiv e) where a par ticular par t is used.
DCA-125USJ (50 HZ) — OPERATION AND PARTS MANUAL — REV. #0 (03/11/05) — PAGE 55 1 DCA-125USJ (50 HZ)— SUGGESTED SP ARE P ARTS P ar t number on this Suggested Spare P ar ts list may supercede/replace the P/N shown in the text pages of this book.
P A GE 56 — DCA-125USJ (50 HZ) — OPERA TION AND P AR TS MANU AL — REV . #0 (03/11/05) DCA-125USJ (50 HZ)— GENERA T OR ASSY . GENERA T OR ASSY .
DCA-125USJ (50 HZ) — OPERATION AND PARTS MANUAL — REV. #0 (03/11/05) — PAGE 57 1 DCA-125USJ (50 HZ)— GENERA T OR ASSY . GENERA T OR ASSY . NO . P AR T NO . P AR T NAME QTY . REMARKS 1 C0110000002 ROT O R ASSY . 1 1-1 * FIELD ASSY . 1 1-2 * 8131070013 F AN 1 1-3 * 8131611014 COUPLING DISK 8 1-4 * 8131015003 BALANCING PLA TE .
P A GE 58 — DCA-125USJ (50 HZ) — OPERA TION AND P AR TS MANU AL — REV . #0 (03/11/05) DCA-125USJ (50 HZ)— CONTR OL BO X ASSY . CONTROL BO X ASSY .
DCA-125USJ (50 HZ) — OPERATION AND PARTS MANUAL — REV. #0 (03/11/05) — PAGE 59 1 DCA-125USJ (50 HZ)— CONTROL BO X ASSY . CONTROL BO X ASSY . NO . P AR T NO . P AR T NAME QTY . REMARKS 1 M3213000702 CONTR OL BO X 1 2 0330000180 EDGING 2 3 0601808823 CIRCUIT BREAKER, 300A .
P A GE 60 — DCA-125USJ (50 HZ) — OPERA TION AND P AR TS MANU AL — REV . #0 (03/11/05) CONTROL BO X ASSY . DCA-125USJ (50 HZ)— CONTR OL BO X ASSY .
DCA-125USJ (50 HZ) — OPERATION AND PARTS MANUAL — REV. #0 (03/11/05) — PAGE 61 1 CONTROL BO X ASSY . NO . P AR T NO . P AR T NAME QTY . REMARKS 3 1 0601840073 RHEOST A T (V O L T A GE REGULA T OR) ............... 1 ........... RA20A2SE102 BJ 2W 1k OHM 3 2 0601840121 KNOB 1 3 3 ECUCAN71 CONTROLLER, 50Hz 1 3 4 0601831340 S W ITCH .
P A GE 62 — DCA-125USJ (50 HZ) — OPERA TION AND P AR TS MANU AL — REV . #0 (03/11/05) DCA-125USJ (50 HZ)— ENGINE AND RADIA T OR ASSY . ENGINE AND RADIA T OR ASSY .
DCA-125USJ (50 HZ) — OPERATION AND PARTS MANUAL — REV. #0 (03/11/05) — PAGE 63 1 ENGINE AND RADIA T OR ASSY . NO . P AR T NO . P AR T NAME QTY . REMARKS 1 M3923200054 ENGINE & RADIA T OR SET ................................. 1 ........ JOHN DEERE 6068TF275 1- 1 0602041292 C A R TRIDGE, OIL FIL TER .
P A GE 64 — DCA-125USJ (50 HZ) — OPERA TION AND P AR TS MANU AL — REV . #0 (03/11/05) DCA-125USJ (50 HZ)— ENGINE AND RADIA T OR ASSY . ENGINE & RADIA T OR ASSY .
DCA-125USJ (50 HZ) — OPERATION AND PARTS MANUAL — REV. #0 (03/11/05) — PAGE 65 1 DCA-125USJ (50 HZ)— ENGINE AND RADIA T OR ASSY . ENGINE & RADIA T OR ASSY .
P A GE 66 — DCA-125USJ (50 HZ) — OPERA TION AND P AR TS MANU AL — REV . #0 (03/11/05) DCA-125USJ (50 HZ)— OUTPUT TERMINAL ASSY . OUTPUT TERMINAL ASSY .
DCA-125USJ (50 HZ) — OPERATION AND PARTS MANUAL — REV. #0 (03/11/05) — PAGE 67 1 DCA-125USJ (50 HZ)— OUTPUT TERMINAL ASSY . OUTPUT TERMINAL ASSY .
P A GE 68 — DCA-125USJ (50 HZ) — OPERA TION AND P AR TS MANU AL — REV . #0 (03/11/05) DCA-125USJ (50 HZ)— B A TTER Y ASSY . BA TTER Y ASSY ..
DCA-125USJ (50 HZ) — OPERATION AND PARTS MANUAL — REV. #0 (03/11/05) — PAGE 69 1 DCA-125USJ (50 HZ)— B A TTER Y ASSY . BA TTER Y ASSY . NO . P AR T NO . P AR T NAME QTY . REMARKS 1 0602220196 B A TTER Y ........................................
P A GE 70 — DCA-125USJ (50 HZ) — OPERA TION AND P AR TS MANU AL — REV . #0 (03/11/05) DCA-125USJ (50 HZ)— MUFFLER ASSY . MUFFLER ASSY ..
DCA-125USJ (50 HZ) — OPERATION AND PARTS MANUAL — REV. #0 (03/11/05) — PAGE 71 1 DCA-125USJ (50 HZ)— MUFFLER ASSY . MUFFLER ASSY . NO . P AR T NO .
P A GE 72 — DCA-125USJ (50 HZ) — OPERA TION AND P AR TS MANU AL — REV . #0 (03/11/05) DCA-125USJ (50 HZ)— FUEL T ANK ASSY . FUEL T ANK ASSY ..
DCA-125USJ (50 HZ) — OPERATION AND PARTS MANUAL — REV. #0 (03/11/05) — PAGE 73 1 DCA-125USJ (50 HZ)— FUEL T ANK ASSY . FUEL T ANK ASSY . NO . P AR T NO .
P A GE 74 — DCA-125USJ (50 HZ) — OPERA TION AND P AR TS MANU AL — REV . #0 (03/11/05) DCA-125USJ (50 HZ)— ENCLOSURE #1 ASSY . ENCLOSURE #1 ASSY .
DCA-125USJ (50 HZ) — OPERATION AND PARTS MANUAL — REV. #0 (03/11/05) — PAGE 75 1 DCA-125USJ (50 HZ)— ENCLOSURE #1 ASSY . ENCLOSURE #1 ASSY . NO . P AR T NO . P AR T NAME QTY . REMARKS 1 M3413001812 BASE 1 2 M3363300303 ENVIR ONMENT AL T ANK 1 3 0016910030 HEX, HEAD BOL T 1 2 4 0603306797 PLUG 1 5 M3423001202 FRONT FRAME .
P A GE 76 — DCA-125USJ (50 HZ) — OPERA TION AND P AR TS MANU AL — REV . #0 (03/11/05) DCA-125USJ (50 HZ)— ENCLOSURE #1 ASSY . ENCLOSURE #1 ASSY .
DCA-125USJ (50 HZ) — OPERATION AND PARTS MANUAL — REV. #0 (03/11/05) — PAGE 77 1 ENCLOSURE #1 ASSY . NO . P AR T NO . P AR T NAME QTY . REMARKS 24 A M3493200614 ACOUSTIC SHEET ........................................... 1 ........... S/N 8500001 T O 8500040 24 A M3493201204 ACOUSTIC SHEET .
P A GE 78 — DCA-125USJ (50 HZ) — OPERA TION AND P AR TS MANU AL — REV . #0 (03/11/05) DCA-125USJ (50 HZ)— ENCLOSURE #2 ASSY . ENCLOSURE #2 ASSY .
DCA-125USJ (50 HZ) — OPERATION AND PARTS MANUAL — REV. #0 (03/11/05) — PAGE 79 1 DCA-125USJ (50 HZ)— ENCLOSURE #2 ASSY . ENCLOSURE #2 ASSY . NO . P AR T NO . P AR T NAME QTY . REMARKS 1 M3443000802 REAR FRAME ..................................
P A GE 80 — DCA-125USJ (50 HZ) — OPERA TION AND P AR TS MANU AL — REV . #0 (03/11/05) DCA-125USJ (50 HZ)— R UBBER SEALS ASSY . R UBBER SEALS ASSY .
DCA-125USJ (50 HZ) — OPERATION AND PARTS MANUAL — REV. #0 (03/11/05) — PAGE 81 1 DCA-125USJ (50 HZ)— R UBBER SEALS ASSY . R UBBER SEALS ASSY . NO .
P A GE 82 — DCA-125USJ (50 HZ) — OPERA TION AND P AR TS MANU AL — REV . #0 (03/11/05) DCA-125USJ (50 HZ)— NAMEPLA TE AND DECALS ASSY . NAMEPLA TE AND DECALS ASSY .
DCA-125USJ (50 HZ) — OPERATION AND PARTS MANUAL — REV. #0 (03/11/05) — PAGE 83 1 DCA-125USJ (50 HZ)— NAMEPLA TE AND DECALS ASSY . NAMEPLA TE AND DECALS ASSY . NO . P AR T NO . P AR T NAME QTY . REMARKS 1 M1550000204 DECAL, NO TE ..............
P A GE 84 — DCA-125USJ (50 HZ) — OPERA TION AND P AR TS MANU AL — REV . #0 (03/11/05) TERMS AND CONDITIONS OF SALE — P AR TS P A YMENT TERMS T er ms of pa yment for par ts are net 10 da ys. FREIGHT POLICY All parts orders will be shipped collect or prepaid with the charges added to the invoice.
DCA-125USJ (50 HZ) — OPERATION AND PARTS MANUAL — REV. #0 (03/11/05) — PAGE 85 1 NO TE P A GE.
P AR TS AND OPERA TION MANUAL OPERA TION AND P AR TS MANUAL Y our Local Dealer is: MQ PO WER A Division of Multiquip Inc. POST OFFICE BO X 6254 CARSON, CA 90749 310-537-3700 • 800-421-1244 F AX: 310-632-2656 E-mail: mqpower@multiquip.com Inter net: www .
An important point after buying a device Multiquip DCA-125USJ (or even before the purchase) is to read its user manual. We should do this for several simple reasons:
If you have not bought Multiquip DCA-125USJ yet, this is a good time to familiarize yourself with the basic data on the product. First of all view first pages of the manual, you can find above. You should find there the most important technical data Multiquip DCA-125USJ - thus you can check whether the hardware meets your expectations. When delving into next pages of the user manual, Multiquip DCA-125USJ you will learn all the available features of the product, as well as information on its operation. The information that you get Multiquip DCA-125USJ will certainly help you make a decision on the purchase.
If you already are a holder of Multiquip DCA-125USJ, but have not read the manual yet, you should do it for the reasons described above. You will learn then if you properly used the available features, and whether you have not made any mistakes, which can shorten the lifetime Multiquip DCA-125USJ.
However, one of the most important roles played by the user manual is to help in solving problems with Multiquip DCA-125USJ. Almost always you will find there Troubleshooting, which are the most frequently occurring failures and malfunctions of the device Multiquip DCA-125USJ along with tips on how to solve them. Even if you fail to solve the problem, the manual will show you a further procedure – contact to the customer service center or the nearest service center
