Instruction/ maintenance manual of the product WR500 Monessen Hearth
Go to page of 24
For use in U.S./Canada Underwriter's Laboratories Report No.
2 WR / W C Series W oodbur ning Fireplace 20014528 .
3 WR / W C Series W oodbur ning Fireplace 20014528 5/8" (16mm) 1/2" (13mm) 1/2" 36" (914mm) 38 56M " (971mm) 40" (1016mm) 5/8" (16mm) 22 6M " (578mm) 1 6M.
4 WR / W C Series W oodbur ning Fireplace 20014528 5/8" (16mm) 1/2" (13mm) 1/2" 42" (1067mm) 38 56M " (971mm) 46" (1 168mm) 5/8" (16mm) 22 6M " (578mm) 1 .
5 WR / W C Series W oodbur ning Fireplace 20014528 Insulation methods shown are optional for cold climate, not a requirement for unit operation. FP554 Fireplace and chase parts identification.
6 WR / W C Series W oodbur ning Fireplace 20014528 0 0 0 0 0 3" 1.
7 WR / W C Series W oodbur ning Fireplace 20014528 L 1 L 1 L T MODEL SK 2 W ALL CHIMNEY TOT AL LENGTH (L T ) INST ALLED LENGTH (L 1 ) SK81 SK818 SK83 SK84 1 1 56O " 17 56O " 35 56O " 47.
8 WR / W C Series W oodbur ning Fireplace 20014528 If .
9 WR / W C Series W oodbur ning Fireplace 20014528 Framing can be constructed before or after the fireplace is set in place, however , most installers build the frame before setting the fireplace. Frame fireplace with 2 x 4 lumber or heavier materials.
10 WR / W C Series W oodbur ning Fireplace 20014528 T o mark the centerline of the flue, put the fireplace in final position and measure out from the wall: 9 ¹⁄₄ " (235mm).
1 1 WR / W C Series W oodbur ning Fireplace 20014528 Safety strips are not required over noncom- bustible floors where all supports at the base of the fireplace are noncombustible. Four (4) nailing flanges are incorporated on each cor- ner of the surround.
12 WR / W C Series W oodbur ning Fireplace 20014528 Continue installing the pipe as required until pipe is installed up through the ceiling. At this point, you must install a firestop spacer .
13 WR / W C Series W oodbur ning Fireplace 20014528 In the U.S., it is a good idea, although not al- ways required, to install an attic insulation shield where blown-in insulation is planned to be used in the attic. Install the attic insulation shield with the flanges on its base extending down into the framing hole.
14 WR / W C Series W oodbur ning Fireplace 20014528 Follow the installation instructions provided with the chimney termination you have selected.
15 WR / W C Series W oodbur ning Fireplace 20014528 MA81 rev . 8/5/97 1 56O " Ref. Combustible materials are permitted within a shaded area shown in Figure 23 titled Minimum W all Clearances. * ** MA81 Combustible mantle clearances.
16 WR / W C Series W oodbur ning Fireplace 20014528 A hearth extension is required to protect a combustible floor in front of the fireplace. Refer to Figure 23 for mini- mum dimensions and mounting detail.
17 WR / W C Series W oodbur ning Fireplace 20014528 COMMON MA TERIALS AND F ACTORS MA TERIAL K* R MINIMUM THICKNESS EH2416 Common Brick 0.458 5.0 1.09 0.50 in.** 0.10 5.46 in.** (MHSC) R V alue is for 1/2 inch. * Units of K = BTU/SQ FT/HR /˚F/IN ** Thickness of Listed Material FP533ADD Addendum 6/1/99 djt 8/4/99 changed .
18 WR / W C Series W oodbur ning Fireplace 20014528 MHSC fireplaces are designed to accept a 1/2" (13 mm) gas line for installation of an approved gas appliance.
19 WR / W C Series W oodbur ning Fireplace 20014528 1 2 3 4 5 a b c 6 7 8 9 10 948 SR/SC parts 5/16/00 djt d 12 1 1 e MHSC reserves the right to make changes in design, materials, specifications, prices and discontinue colors and products at any time, without notice.
20 WR / W C Series W oodbur ning Fireplace 20014528 The following accessories for this appliance are available from your local MHSC distributor . Should you need addi- tional information beyond what your distributor can furnish, contact: MHSC, 149 Cleveland Drive, Paris, KY 40361, Attn: T echnical Services.
21 WR / W C Series W oodbur ning Fireplace 20014528 Round T op T ermination T op used to terminate chimney at roof. RL TSK8 (Flashing not included.) Round T op T ermination - T op used to terminate chimney at chase.
22 WR / W C Series W oodbur ning Fireplace 20014528 Chimney Collar Enclosure Installs on the "over the chimney collar" of the CCE-SK fireplace; provides outside air to assist in cooling the chimney system. Attic Insulation Shield Used to prevent insulation from coming in AIS-SK contact with the chimney system.
23 WR / W C Series W oodbur ning Fireplace 20014528 .
149 Cleveland Drive • Paris, Kentucky 40361 www .mhsc.com 20014528 10/08 Rev . 2.
An important point after buying a device Monessen Hearth WR500 (or even before the purchase) is to read its user manual. We should do this for several simple reasons:
If you have not bought Monessen Hearth WR500 yet, this is a good time to familiarize yourself with the basic data on the product. First of all view first pages of the manual, you can find above. You should find there the most important technical data Monessen Hearth WR500 - thus you can check whether the hardware meets your expectations. When delving into next pages of the user manual, Monessen Hearth WR500 you will learn all the available features of the product, as well as information on its operation. The information that you get Monessen Hearth WR500 will certainly help you make a decision on the purchase.
If you already are a holder of Monessen Hearth WR500, but have not read the manual yet, you should do it for the reasons described above. You will learn then if you properly used the available features, and whether you have not made any mistakes, which can shorten the lifetime Monessen Hearth WR500.
However, one of the most important roles played by the user manual is to help in solving problems with Monessen Hearth WR500. Almost always you will find there Troubleshooting, which are the most frequently occurring failures and malfunctions of the device Monessen Hearth WR500 along with tips on how to solve them. Even if you fail to solve the problem, the manual will show you a further procedure – contact to the customer service center or the nearest service center
