Instruction/ maintenance manual of the product N200 Lenovo
Go to page of 165
Le n o v o 3 000 N1 00 an d N2 00 Hard w ar e M ain t e n a n c e Ma nu a l June 2007 This manual supports: Lenovo 3000 N100 (MT 0689 and 0768) Lenovo 3000 N200 (MT 0769).
.
Le n o v o 3 000 N1 00 an d N2 00 Hard w ar e M ain t e n a n c e Ma nu a l.
Note Before using this information and the pr oduct it supports, be sure to r ead the general information under “Notices” on page 155. Second Edition (June 2007) © Copyright Lenovo 2007.
Contents Introduction . . . . . . . . . . . . .1 About this manual . . . . . . . . . . . .1 Important service information . . . . . . . .1 Strategy for replacing FRUs . . . . . . . . .1 Strategy for replacing a har d disk drive . . . .2 Important notice for replacing a system boar d .
iv MT 0689, 0768, and 0769.
Introduction About this manual This manual contains service and refer ence information for Lenovo 3000 N100 and N200 (MT 0689, 0768, and 0769). Use this manual along with the advanced diagnostic tests to troubleshoot pr oblems.
v If you are instructed to replace a FRU but the replacement does not correct the problem, reinstall the original FRU before you continue . v Some computers have both a processor boar d and a system board.
Using PC Entitlement W arehouse (PEW) v PEW is the primary source for identifying FRU part numbers and FRU descriptions for the key commodities for CMV products at a MT - serial number level. An example of key commodities are har d disk drives, system boards, micropr ocessors, Liquid Crystal Displays (LCDs), and memory .
Important information about replacing RoHS compliant FRUs RoHS, The Restriction of Hazardous Substances in Electrical and Electronic Equipment Directive (2002/95/EC) is a European Union legal requirement affecting the global electronics industry . RoHS requirements must be implemented on Lenovo products placed on the market after June 2006.
Diskette compatibility matrix The compatibility of each of the drives with the diskettes for it is as follows: Diskette drive Diskette capacity Compatibility 3.
Safety notice 2 D ANGER Some standby batteries contain a small amount of nickel and cadmium. Do not disassemble a standby battery , recharge it, throw it into fire or water , or short-circuit it. Dispose of the battery as required by local ordinances or regulations.
Safety notice 3 D ANGER The battery pack contains small amounts of nickel. Do not disassemble it, throw it into fire or water , or short-circuit it. Dispose of the battery pack as required by local ordinances or regulations. Use only the battery in the appropriate parts listing when replacing the battery pack.
Safety notice 4 D ANGER The lithium battery can cause a fire, an explosion, or a severe burn. Do not recharge it, remove its polarized connector , disassemble it, heat it above 100°C (212°F), incinerate it, or expose its cell contents to water . Dispose of the battery as required by local ordinances or regulations.
Safety notice 5 Safety notice 6 D ANGER If the LCD breaks and the fluid fr om inside the LCD gets into your eyes or on your hands, immediately wash the affected ar eas with water for at least 15 minutes. Seek medical care if any symptoms fr om the fluid are present after washing.
Safety notice 7 D ANGER Safety notice 8 D ANGER Though the main batteries have low voltage, a shorted or grounded battery can produce enough current to burn personnel or combustible materials.
Safety information The following section presents safety information with which you need to be familiar before you service a Lenovo 3000 computer . General safety Follow these rules to ensur e general safety: v Observe good housekeeping in the area of the machines during and after maintenance.
Important Use only approved tools and test equipment. Some hand tools have handles covered with a soft material that does not insulate you when working with live electrical currents. Many customers have, near their equipment, rubber floor mats that contain small conductive fibers to decrease electr ostatic discharges.
v Do not service the following parts with the power on when they are r emoved from their normal operating places in a machine: – Power supply units – Pumps – Blowers and fans – Motor generators and similar units. (This practice ensures corr ect grounding of the units.
Handling devices that are sensitive to electrostatic discharge Any computer part containing transistors or integrated circuits (ICs) should be considered sensitive to electr ostatic discharge (ESD.) ESD damage can occur when there is a dif ference in charge between objects.
Laser compliance statement Some models of Lenovo 3000 computer are equipped fr om the factory with an optical storage device such as a CD-ROM drive or a DVD-ROM drive. Such devices are also sold separately as options. If one of these drives is installed, it is certified in the U.
A CD-ROM drive, a DVD-ROM drive, or any other storage device installed may contain an embedded Class 3A or Class 3B laser diode. Note the following: D ANGER Emits visible and invisible laser radiation when open. Do not stare into the beam, do not view directly with optical instruments, and avoid direct exposure to the beam.
General descriptions The descriptions in this chapter apply to any Lenovo 3000 model that has the PC-Doctor ® for DOS diagnostics program. Some descriptions might not apply to your particular computer . Read this first Before you go to the checkout guide, be sur e to read this section.
Following is a list of some common items that are not cover ed under warranty and some symptoms that might indicate that the system was subjected to stress beyond normal use.
Related service information This section provides information about the following: v “Service We b site” v “Restoring the factory contents by using Product Recovery discs” v “Passwords” on.
9. When prompted, insert the appr opriate Product Recovery disc and then click OK . The second phase of the recovery pr ocess begins. 10. When all of the data has been copied from the last Pr oduct Recovery disc in the set, a message is displayed prompting you to r estart the computer .
How to remove the power-on password To remove a POP that you have forgotten, do the following: (A) If no SVP has been set: 1. T urn off the computer . 2. Remove the battery pack. For how to remove the battery pack, see “1010 Battery pack” on page 46.
How to remove the hard-disk password Attention: If User only mode is selected and the user HDP has been forgotten and cannot be made available to the servicer , neither Lenovo nor Lenovo authorized servicers provide any services to r eset the user HDPs or to recover data from the har d disk drive.
v If the battery indicator blinks orange, indicating that the battery power is low . (Alternatively , if Hibernate when battery becomes low has been selected in the “Power Management Properties” window , the computer goes into hibernation mode.
Checkout guide Use the following procedur es as a guide in identifying and correcting problems with the Lenovo 3000 computer . Note: The diagnostic tests are intended to test only Lenovo 3000 pr oducts. The use of non-Lenovo 3000 products, pr ototype cards, or modified options can lead to false indications of errors and invalid system r esponses.
To run the test, do as follows: 1. Insert the PC-Doctor disk into the diskette drive; then power on the computer . If the computer cannot be powered on, go to “Power system checkout” on page 26, and check the power sources. If an error code appears, go to “Symptom-to-FRU index” on page 36.
Detecting system information with PC-Doctor PC-Doctor can detect the following system information: Hardware Info v System Configuration v Memory Contents v Physical Disk Drives v Logical Disk Drives v.
Checking the ac adapter Yo u are her e because the computer fails only when the ac adapter is used. v If the power-on indicator does not turn on, check the power cor d of the ac adapter for correct continuity and installation. v If the computer does not charge during operation, go to ″ Checking operational charging.
Note: If the battery pack becomes hot, it may not be able to charge. Remove it from the computer and leave it at r oom temperature for a while. After it cools down, reinstall and r echarge it. To check the battery pack, do the following: 1. Power off the computer .
Lenovo 3000 N100 and N200 Product overview . . . . . . . . . . . .3 0 Specifications . . . . . . . . . . . . .3 0 Status indicators . . . . . . . . . . . .3 3 FRU tests . . . . . . . . . . . . . .3 4 Fn key combinations . . . . . . . . . .3 5 Symptom-to-FRU index .
Product overview This section presents the following pr oduct-unique information: v “Specifications” v “Status indicators” on page 33 v “FRU tests” on page 34 v “Fn key combinations” o.
31 Feature Description Processor • Intel Celeron processor 530 (1.73GHz 533MHz 1MBL2) • Intel Celeron proce ssor 550 (2.0GHz 533MHz 1MBL2) • Intel Core 2 Duo pr ocessor T5550 (1.83GHz 667MHz 2MBL2) • Intel Core 2 Duo pr ocessor T2330 (1.6GHz 533MHz 1MBL2) • Intel Core 2 Duo pr ocessor T2310 (1.
32 Hard disk drive • 40 GB , 5400 rpm, 9.5 mm high, SA T A interface • 60 GB, 5400 rpm, 9.5 mm high, SA T A interface • 80 GB, 5400 rpm, 9.5 mm high, SA T A interface • 100 GB, 5400 rpm, 9.5 mm high, SA T A interface • 120 GB, 5400 rpm, 9.5 mm high, SA T A interface • 160 GB, 5400 rpm, 9.
Status indicators The system status indicators show the status of the computer , as follows: 1 2 3 4 5 6 7 8 Indicator Meaning 1 Caps lock Caps Lock mode is enabled. Yo u can enter all alphabetic characters (A-Z) in uppercase without pr essing the Shift key .
Indicator Meaning 6 Bluetooth status R Green: Bluetooth wireless is operational. This indicator is on when Bluetooth wireless is on and not in suspend mode. 7 Battery status Green: The battery is charged between 80% to 100% of the capacity , and being discharged between 0% to 80% of the capacity .
Fn key combinations The following table shows the function of each combination of Fn with a function key . Key combination Description Fn+F1 V olume down. Fn+F2 V olume up. Fn+F3 Reserved. Fn+F4 Put the computer in sleep (standby) mode. To return to normal operation, press the Fn key only , without pressing a function key .
Symptom-to-FRU index The symptom-to-FRU index in this section lists symptoms and errors and their possible causes. The most likely cause is listed first, in boldface type. Note: Do the FRU replacement or other actions in the sequence shown in the column headed “FRU or action, in sequence.
Symptom or error FRU or action, in sequence 0260 System timer error 1. Charge the backup battery for more than 8 hours by connecting the ac adapter . 2. Replace the backup battery and run BIOS Setup Utility to reset the time and date. 3. System board.
Error messages Symptom or error FRU or action, in sequence Unsupported memory . DIMM . Make sur e to use supported memory . Device address conflict. 1. Load “Setup Defaults” in the BIOS Setup Utility . 2. Backup battery . 3. System board. Allocation error for device.
No-beep symptoms Symptom or error FRU or action, in sequence No beep, power-on indicator on, LCD blank, and no POST . 1. Make sure that every connector is connected tightly and correctly . 2. DIMM. 3. System board. No beep, power-on indicator on, and LCD blank during POST .
LCD-related symptoms Important The TFT LCD for the notebook computer contains many thin-film transistors (TFT s). The presence of a small number of dots that ar e missing, discolored, or always lighted is characteristic of TFT LCD technology , but excessive pixel problems can cause viewing concerns.
Intermittent problems Intermittent system hang problems can be due to a variety of causes that have nothing to do with a hardwar e defect, such as cosmic radiation, electrostatic discharge, or softwar e errors. FRU replacement should be consider ed only when a problem r ecurs.
FRU replacement notices This section contains notices related to r emoving and replacing parts. Read this section carefully befor e replacing any FRU. Screw notices Loose screws can cause a r eliability problem.
v “Retaining the UUID” v “Reading or writing the ECA information” Restoring the serial number of the system unit When the computer was manufactured, the EEPROM on the system boar d was loaded with the serial numbers of the system and all major components.
To check what ECAs have been previously applied to the machine, use the ECA Information Read/W rite function on the CE Utility Diskette for Lenovo 3000 notebooks. 1. Insert the CE Utility Diskette for Lenovo 3000 notebooks, and restart the computer . 2.
Removing and replacing a FRU This section presents dir ections and drawings for use in removing and replacing a FRU. Be sure to observe the following general r ules: 1. Do not try to service any computer unless you have been trained and certified. An untrained person runs the risk of damaging parts.
1010 Battery pack D ANGER Unlock the battery release lever 1 and holding the battery r elease lever in the unlocked position 2 , remove the battery pack in the dir ection shown by arrow 3 . 3 2 1 Use only the battery specified in the parts list for your computer .
1020 Hard disk drive slot cover For access, remove this FRU: v “1010 Battery pack” on page 46 1 1 2 For MT 0689 and 0768 Step Screw (quantity) Color T orque 1 M2.5 × 4 mm, flat-head, nylon-coated (2) Silver 0.392 Nm (4 kgfcm) For MT 0769 Step Screw (quantity) Color T orque 1 M2.
1030 Hard disk drive For access, remove these FRUs in or der: v “1010 Battery pack” on page 46 v “1020 Hard disk drive slot cover” on page 47 Attention v Do not drop the hard disk drive or apply any physical shock to it. The hard disk drive is sensitive to physical shock.
1040 PCI Express Mini Card for 802.1 1 a/b/g wireless LAN For access, remove these FRUs in or der: v “1010 Battery pack” on page 46 v “1020 Hard disk drive slot cover” on page 47 For MT 0689 and 0768 1 1 2 3 Step Screw (quantity) Color T orque 1 M2 × 4 mm, flat-head, nylon-coated (2) Black 0.
For MT 0769 1 1 2 3 Step Screw (quantity) Color T orque 1 M2.5 × 3 mm, pan-head, nylon-coated (2) Silver 0.392 Nm (4 kgfcm) In step 2 , unplug the jacks by using the removal tool antenna RF connector (P/N: 08K7159) or pick the connectors with your fingers and gently unplug them in direction of the arr ow .
1050 PCI Express Mini Card for 802.1 1 a/b/g/n wireless LAN For access, remove these FRUs in or der: v “1010 Battery pack” on page 46 v “1020 Hard disk drive slot cover” on page 47 For MT 0689 and 0768 1 1 2 3 Step Screw (quantity) Color T orque 1 M2 × 4 mm, flat-head, nylon-coated (2) Black 0.
For MT 0769 1 1 2 3 Step Screw (quantity) Color T orque 1 M2.5 × 3 mm, pan-head, nylon-coated (2) Silver 0.392 Nm (4 kgfcm) In step 2 , unplug the jacks by using the removal tool antenna RF connector (P/N: 08K7159) or pick the connectors with your fingers and gently unplug them in direction of the arr ow .
1060 DIMM slot cover For access, remove this FRU: v “1010 Battery pack” on page 46 1 2 For MT 0689 and 0768 Step Screw (quantity) Color T orque 1 M2.5 × 4 mm, flat-head, nylon-coated (1) Silver 0.392 Nm (4 kgfcm) For MT 0769 Step Screw (quantity) Color T orque 1 M2.
1070 DIMM For access, remove these FRUs in or der: v “1010 Battery pack” on page 46 v “1060 DIMM slot cover” on page 53 1 1 2 When installing: Insert the notched end of the DIMM into the socket. Press the DIMM firmly , and pivot it until it snaps into the place.
1080 Optical drive For access, remove these FRUs in or der: v “1010 Battery pack” on page 46 v “1060 DIMM slot cover” on page 53 (only for MT 0689) For MT 0689 2 3 1 Step Screw (quantity) Color T orque 1 M2.5 × 4 mm, flat-head, nylon-coated (1) Silver 0.
For MT 0768 and 0769 3 2 1 For MT 0768 Step Screw (quantity) Color T orque 1 M2.5 × 4 mm, flat-head, nylon-coated (1) Silver 0.392 Nm (4 kgfcm) For MT 0769 Step Screw (quantity) Color T orque 1 M2.5 × 4 mm, pan-head, nylon-coated (1) Silver 0.
1090 Thermal module slot cover For access, remove this FRU: v “1010 Battery pack” on page 46 1 2 1 For MT 0689 and 0768 Step Screw (quantity) Color T orque 1 M2.5 × 4 mm, flat-head, nylon-coated (2) Silver 0.392 Nm (4 kgfcm) For MT 0769 Step Screw (quantity) Color T orque 1 M2.
1 100 Fan For access, remove this FRU: v “1010 Battery pack” on page 46 v “1090 Thermal module slot cover” on page 57 2 3 1 1 1 For MT 0689 Step Screw (quantity) Color T orque 1 M2.5 × 5 mm, flat-head, nylon-coated (3) Black 0.392 Nm (4 kgfcm) For MT 0768 Step Screw (quantity) Color T orque 1 M2.
111 0 Thermal module For access, remove these FRUs in or der: v “1010 Battery pack” on page 46 v “1090 Thermal module slot cover” on page 57 v “1 100 Fan” on page 58 For MT 0689 and 0768 1 1 1 1 2 Step Screw (quantity) Color T orque 1 CPU thermal screw , nylon-coated (4) Silver 0.
For MT 0769 2 1 1 1 When installing: Make sure that the connector is attached firmly . 3 (continued) Removing and replacing a FRU 60 MT 0689, 0768, and 0769.
When installing: Before you attach a new thermal module to the computer , peel off the covering film of thermal gr ease. Then attach the thermal module to the computer .
1 120 CPU For access, remove these FRUs in or der: v “1010 Battery pack” on page 46 v “1090 Thermal module slot cover” on page 57 v “1 100 Fan” on page 58 v “ 111 0 Thermal module” on page 59 Attention: CPU is extremely sensitive. When you service the CPU, avoid any kind of rough handling.
1 130 Cover , strip (E cover) For access, remove this FRU: v “1010 Battery pack” on page 46 2 1 3 3 Removing and replacing a FRU Lenovo 3000 N100 and N200 63.
1 140 Bluetooth daughter card (BDC) for MT 0769 For access, remove this FRU: v “1010 Battery pack” on page 46 v “1 130 Cover , strip (E cover)” on page 63 1 2 3 Step Screw (quantity) Color T orque 1 M2.5 × 3 mm, pan-head, nylon-coated (1) Silver 0.
1 150 Keyboard For access, remove these FRUs in or der: v “1010 Battery pack” on page 46 v “1 130 Cover , strip (E cover)” on page 63 1 1 For MT 0689 and 0768 Step Screw (quantity) Color T orque 1 M2.5 × 3 mm, flat-head, nylon-coated (2) Black 0.
In step 2 , unlatch the keyboard. 2 When installing: Make sure that the latch is attached firmly . Then secure the screws. Lift the keyboard a little in the dir ection shown by arrow 4 . Then unlock the connector 5 and detach the connector .
3 4 4 5 When installing: 1. Make sure that the keyboar d connector is attached firmly . Then lock the connector . 2. Make sure that the fr ont side of the keyboard is under the frame.
1 160 Function board For access, remove these FRUs in or der: v “1010 Battery pack” on page 46 v “1 130 Cover , strip (E cover)” on page 63 v “1 150 Keyboard” on page 65 1 1 3 2 2 For MT 0689 and 0768 Step Screw (quantity) Color T orque 1 M2.
1 170 LCD unit For access, remove these FRUs in or der: v “1010 Battery pack” on page 46 v “1020 Hard disk drive slot cover” on page 47 v “1040 PCI Express Mini Car d for 802.1 1 a/b/g wireless LAN” on page 49 v “1050 PCI Express Mini Car d for 802.
For MT 0768 and 0769 Note: Step 1a is only for MT 0769. 1a 1 For MT 0768 Step Screw (quantity) Color T orque 1 M2.5 × 6 mm, flat-head, nylon-coated (1) Silver 0.392 Nm (4 kgfcm) For MT 0769 Step Screw (quantity) Color T orque 1 M2.5 × 6 mm, pan-head, nylon-coated (1) Silver 0.
Pull out the wireless LAN antenna cables fr om the guide hole of the system board 2 , and release them fr om the cable guides of the frame 3 . For MT 0689 and 0768 3 2 5 4 6 When installing: Make sure that the connectors 4 , 5 , and 6 ar e attached firmly .
For MT 0769 Pull out the wireless LAN antenna cables fr om the guide hole of the system board 2 , and release them fr om the cable guides of the frame 3 . Pull out the LCD cable from the hole of the system boar d 6 . 3 2 2 4 5 6 When installing: Make sure that the connectors 4 and 5 ar e attached firmly .
For MT 0689 8 8 7 7 Step Screw (quantity) Color T orque 7 M2.5 × 8 mm, flat-head, nylon-coated (2) Silver 0.392 Nm (4 kgfcm) When installing: Route the antenna cables along the cable guides. When you route the cables, do not tense them. To do so, the cables may get damaged by the cable guides of the frame, and may cause a broken wir e.
For MT 0768 and 0769 8 8 7 7 For MT 0768 Step Screw (quantity) Color T orque 7 M2.5 × 6 mm, flat-head, nylon-coated (4) Silver 0.392 Nm (4 kgfcm) For MT 0769 Step Screw (quantity) Color T orque 7 M2.5 × 6 mm, pan-head, nylon-coated (4) Silver 0.
1 180 To p cover assembly (C cover) with speakers and Bluetooth daughter card (BDC) for MT 0689 and 0768 For access, remove these FRUs in or der: v “1010 Battery pack” on page 46 v “1020 Hard disk drive slot cover” on page 47 v “1040 PCI Express Mini Car d for 802.
Note: Step 3a is only for MT 0689. 3a 3a Step Screw (quantity) Color T orque 3a M2.5 × 6 mm, flat-head, nylon-coated (2) Black 0.392 Nm (4 kgfcm) For MT 0768 Note: Step 1b is only for MT 0768 1b Step Screw (quantity) Color T orque 1b M2.
Note: Steps 2b and 3b are only for MT 0768. 2b 2b 2b 2b 2b 2b 2b 2b 2b 2b Step Screw (quantity) Color T orque 2b M2.5 × 6 mm, flat-head, nylon-coated (17) Black 0.392 Nm (4 kgfcm) 3b Step Screw (quantity) Color T orque 3b M2.5 × 6 mm, flat-head, nylon-coated (2) Black 0.
4 When installing: Make sure that the connectors ar e attached firmly . 5 5 5 5 5 5 (continued) Removing and replacing a FRU 78 MT 0689, 0768, and 0769.
The Bluetooth daughter card is attached underside of the top cover assembly . To remove the Bluetooth daughter card, do as follows: 2 1 1 Step Screw (quantity) Color T orque 1 M2 × 4 mm, flat-head, nylon-coated (2) Black 0.245 Nm (2.5 kgfcm) When installing: Make sure that the connector is attached firmly .
1 190 To p cover assembly (C cover) for MT 0769 For access, remove these FRUs in or der: v “1010 Battery pack” on page 46 v “1020 Hard disk drive slot cover” on page 47 v “1040 PCI Express Mini Car d for 802.1 1 a/b/g wireless LAN” on page 49 v “1050 PCI Express Mini Car d for 802.
2 2 2 2 2 2 2 2 2 2 3 Step Screw (quantity) Color T orque 2 M2.5 × 8 mm, pan-head, nylon-coated (16) Silver 0.392 Nm (4 kgfcm) 3 M2.5 × 10 mm, pan-head, nylon-coated (1) Silver 0.392 Nm (4 kgfcm) 4 Step Screw (quantity) Color T orque 4 M2.
5 When installing: Make sure that the connectors ar e attached firmly . 6 6 6 6 6 6 Removing and replacing a FRU 82 MT 0689, 0768, and 0769.
1200 USB/Audio connector card For access, remove these FRUs in or der: v “1010 Battery pack” on page 46 v “1020 Hard disk drive slot cover” on page 47 v “1040 PCI Express Mini Car d for 802.1 1 a/b/g wireless LAN” on page 49 v “1050 PCI Express Mini Car d for 802.
1210 VGA connector card For access, remove these FRUs in or der: v “1010 Battery pack” on page 46 v “1020 Hard disk drive slot cover” on page 47 v “1040 PCI Express Mini Car d for 802.1 1 a/b/g wireless LAN” on page 49 v “1050 PCI Express Mini Car d for 802.
For MT 0769 2 3 1 Step Screw (quantity) Color T orque 1 M2.5 × 4 mm, pan-head, nylon-coated (1) Silver 0.392 Nm (4 kgfcm) When installing: Make sure that the connector is attached firmly .
1220 System board, MDC, PC Card slot, and bottom cover assembly (D cover) for MT 0689 and 0768 For access, remove these FRUs, in or der: v “1010 Battery pack” on page 46 v “1020 Hard disk drive slot cover” on page 47 v “1030 Hard disk drive” on page 48 v “1040 PCI Express Mini Car d for 802.
2 3 Step Screw (quantity) Color T orque 2 M2.5 × 3 mm, flat-head, nylon-coated (1) Black 0.392 Nm (4 kgfcm) In step 3 , remove the system boar d, the MDC, and the PC Card slot together from the bottom cover . To remove the MDC, do as follows: 1 1 2 Step Screw (quantity) Color T orque 1 M2.
To remove the PC Card slot assembly , do as follows: 1 1 1 1 2 Step Screw (quantity) Color T orque 1 M2 × 4 mm, flat-head, nylon-coated (4) Silver 0.245 Nm (2.5 kgfcm) When installing: Make sure that the connectors of PC Car d slot assembly is attached to the system board firmly , and then fasten the screws.
Note: Applying labels to the bottom cover When you replace the base cover , you need to stick some labels on the new base cover . Some of the labels have been shipped with the new base cover , and some may need to be reused fr om the old base cover .
1230 System board, MDC, ExpressCard slot, heat sink assembly , and bottom cover assembly (D cover) for MT 0769 For access, remove these FRUs, in or der: v “1010 Battery pack” on page 46 v “1020 Hard disk drive slot cover” on page 47 v “1030 Hard disk drive” on page 48 v “1040 PCI Express Mini Car d for 802.
2 2 3 3 4 Step Screw (quantity) Color T orque 2 M2.5 × 4 mm, pan-head, nylon-coated (2) Silver 0.392 Nm (4 kgfcm) When installing: Make sure that the connectors ar e attached firmly .
5 In step 5 , remove the system boar d, the MDC, the ExpressCard slot and the heat sink assembly together from the bottom cover . To remove the MDC, do as follows: 1 1 2 Step Screw (quantity) Color T orque 1 M2.5 × 3 mm, pan-head, nylon-coated (2) Silver 0.
To remove the ExpressCar d slot, do as follows: 1 1 Step Screw (quantity) Color T orque 1 M2 × 4 mm, pan-head, nylon-coated (2) Black 0.245 Nm (2.5 kgfcm) 2 When installing: Make sure that the connectors of Expr essCard slot is attached to the system board firmly , and then fasten the screws.
To remove the heat sink assembly , do as follows: For discrete models 2 1 1 3 Step Screw (quantity) Color T orque 1 Thermal screw , nylon-coated (4) Silver 0.392 Nm (4 kgfcm) 2 M2.5 × 3 mm, pan-head, nylon-coated (1) Silver 0.392 Nm (4 kgfcm) For integrated models 2 1 Step Screw (quantity) Color T orque 1 M2.
Note: Applying labels to the bottom cover When you replace the base cover , you need to stick some labels on the new base cover . Some of the labels have been shipped with the new base cover , and some may need to be reused fr om the old base cover .
2010 LCD front bezel (B cover) For access, remove this FRU: v “1010 Battery pack” on page 46 For MT 0698 and 0768 1b 1a 1a 1b Note: Screws 1a ar e only for MT0768. Step Screw cap Screw (quantity) Color T orque 1a M2.5 × 5 mm, flat-head, nylon-coated (2) Black 0.
In step 2 , while sliding the LCD latch lever in the direction shown by the arr ow , remove the bezel in the dir ection shown by arrow 3 . 2 3 3 Removing and replacing a FRU Lenovo 3000 N1.
2020 Inverter card For access, remove these FRUs in or der: v “1010 Battery pack” on page 46 v “2010 LCD front bezel (B cover)” on page 96 1 3 4 2 For MT 0698 and 0768 Step Screw (quantity) Color T orque 1 M2.5 × 5 mm, flat-head, nylon-coated (1) Black 0.
2030 LCD panel, LCD cable, and hinges For access, remove these FRUs in or der: v “1010 Battery pack” on page 46 v “1020 Hard disk drive slot cover” on page 47 v “1040 PCI Express Mini Car d for 802.1 1 a/b/g wireless LAN” on page 49 v “1050 PCI Express Mini Car d for 802.
For MT 0769 1 2 1 Step Screw (quantity) Color T orque 1 M2.5 × 5 mm, pan-head, nylon-coated (2) Black 0.392 Nm (4 kgfcm) (continued) Removing and replacing a FRU 100 MT 0689, 0768, and 0769.
Remove the hinges ( a ) from the LCD panel. 3b 3a 3a 3b 4 4 a a 3a 3a Note: Screws 3b ar e only for MT 0768 and 0769. For MT 0689 and 0768 Step Screw (quantity) Color T orque 3a M2 × 3 mm, flat-head, nylon-coated (4) Silver 0.245 Nm (2.
2040 Camera and LCD rear cover assembly (A cover) For access, remove these FRUs in or der: v “1010 Battery pack” on page 46 v “1020 Hard disk drive slot cover” on page 47 v “1040 PCI Express Mini Car d for 802.1 1 a/b/g wireless LAN” on page 49 v “1050 PCI Express Mini Car d for 802.
For MT 0768 and 0769 1 Removing and replacing a FRU Lenovo 3000 N100 and N200 103.
Locations Front view 1 Lenovo Care button 2 V olume control buttons 3 Built-in stereo speaker (right) *1 4 Keyboard 5 Fingerprint reader (for some models) 6 T ouch .
Rear view 1 RJ-1 1 (modem) connector 2 AC power connector 3 S-V ideo connector 4 External monitor connector 5 Optical drive 6 USB connectors 7 Microphone jack.
Parts list v Each FRU is available for all types or models, unless specific types or models are specified. v FRU with specific models listed and described as xxU (where U is an example of a country designator) should be used for all models ending in U.
Overall 1 2 3 4 5 6 9 8 a 10 11 12 13 14 16 17 18 19 b c 22 20 7 15 23 24 21 Parts list Lenovo 3000 N100 and N200 107.
No. FRU FRU no. RoHS ID CRU ID a - c See “Miscellaneous parts” on page 152. 1 LCD unit (see “LCD FRUs” on page 129.) 2 Cover , strip (E cover) for MT 0689 and 0768 41W21 15 R N Cover , strip for MT 0769 41R7807 R N 3 Keyboard (see “Keyboar d” on page 136.
No. FRU FRU no. RoHS ID CRU ID 5 To p cover assembly , 15W (C cover) without fingerprint reader for MT 0768 v 0768-2Ax, 34x, 35x, 36x, 37x, 38x, 3Fx, 3Gx, 3Hx, 3Jx, 3Kx, 3Lx, 3Mx, 3Nx, 3Px, 3Qx, 3Rx, .
No. FRU FRU no. RoHS ID CRU ID 6 System board assembly , 14W v 0689- 2xx, 3xx, 4xx, 5xx, 6xx, 7xx, 8xx, K2x, Axx, Bxx, Cxx, Dxx 41W1 199 R N System board assembly , 14W v 0689-Exx, Fxx, Gxx 41W8031 R .
Lenovo 3000 N100 and N200 1 1 1 P ar ts list No. FRU FRU no. RoHS ID CRU ID 6 System board assembly , 15W integrated 0768-E5x, E6x, EGx, EHx, EJx, ELx, F3x, F4x, F6x, F7x, FBx, FGx, FHx, G2x, G3x, GFx.
1 12 MT 0689, 0768, and 0769 P ar ts list No. FRU FRU no. RoHS ID CRU ID 6 System board assembly , 15W discrete 0769-CZx, A8x, A9x, Adx, B2x, B3x, G2x, G6x, Acx, D2x, CVx, CWx, CXx, D4x, G3x.
Lenovo 3000 N100 and N200 1 13 P ar ts list No. FRU FRU no. RoHS ID CRU ID 8 DVD/CD-R W combo drive assembly , 12.7 mm, TSST (TS-L462C CO01) 0689-24x, 25x, 26x, 2Ex, 2Hx, 2Jx, 2Lx, 2Mx, 2Nx, 2Px, 2Qx,.
1 14 MT 0689, 0768, and 0769 P ar ts list No. FRU FRU no. RoHS ID CRU ID 8 DVD-RAM/R W drive assembly , 12.7 mm, TSST (TS-L632C) 0689-22x, 27x, 28x, 29x, 2Ax, 2Bx, 2Fx, 2Kx, 2Tx, 33x, 34x, 3Bx, 3Cx, 3.
Lenovo 3000 N100 and N200 1 15 P ar ts list No. FRU FRU no. RoHS ID CRU ID 10 USB/Audio connector card for MT 0689 and 0768 41W1316 R N USB/Audio connector card for MT 0689 and 0768 (updated) 41R7813 .
1 16 MT 0689, 0768, and 0769 P ar ts list No. FRU FRU no. RoHS ID CRU ID 12 SA T A hard disk drive, 80 GB, 9.5 mm, 5,400 rpm, T oshiba 0689-22x, 27x, 28x, 29x, 2Ex, 2Hx, 2Jx, 2Kx, 2Mx, 2Nx, 2Px, 2Qx, .
Lenovo 3000 N100 and N200 1 17 P ar ts list No. FRU FRU no. RoHS ID CRU ID 12 SA T A hard disk drive, 80 GB, 9.5 mm, 5,400 rpm, Fujitsu 0689-A4x, A6x, ADx, AEx, AFx, AGx, AHx, AJx, B4x, B5x, B6x, B9x,.
1 18 MT 0689, 0768, and 0769 P ar ts list No. FRU FRU no. RoHS ID CRU ID 12 SA T A hard disk drive, 100 GB, 9.5 mm, 5,400 rpm, Fujitsu 0689-A5x, A7x, B7x, BCx, C7x, C8x, C9x, CBx, CGx, CHx, CYx, D5x, .
Lenovo 3000 N100 and N200 1 19 P ar ts list No. FRU FRU no. RoHS ID CRU ID 13 Intel PRO W ireless 3945ABG Mini-PCI Express Adapter 0689-22x, 24x, 28x, 29x, 2Ax, 2Bx, 2Ex, 2Fx, 2Kx, 2Qx, 2Sx, 2Tx, 33x,.
120 MT 0689, 0768, and 0769 P ar ts list No. FRU FRU no. RoHS ID CRU ID 13 Broadcom 802.1 1bg WLAN PCI-E Mini Card 0689-A8x, A9x, AAx, ABx, B2x, BAx, C3x, C5x, CCx, CVx, D2x, E2x, E4x, EAx, G8x, GLx, .
Lenovo 3000 N100 and N200 121 P ar ts list No. FRU FRU no. RoHS ID CRU ID 15 512-MB DDR2-667 SDRAM SO-DIMM (PC2-5300) card 0689-22x, 24x, 25x, 26x, 27x, 28x, 29x, 2Ax, 2Bx, 2Ex, 2Fx, 2Hx, 2Jx, 2Kx, 2L.
122 MT 0689, 0768, and 0769 P ar ts list No. FRU FRU no. RoHS ID CRU ID 15 1-GB DDR2-667 SDRAM SO-DIMM (PC2-5300) card 0689-6Gx, A7x, CGx, CLx, CMx, CNx, CPx, CYx, D5x, DBx, DCx 0768-5Bx, 7Yx, A2x, AJ.
Lenovo 3000 N100 and N200 123 P ar ts list No. FRU FRU no. RoHS ID CRU ID 19 Fan for MT 0768, discrete 0768-21x, 22x, 27x, 28x, 2Cx, 3Yx, 46x, 4Ex, 4Fx, 4Gx, 4Hx, 4Lx, 4Sx, 52x, 53x, 54x, 57x, 58x, 59.
124 MT 0689, 0768, and 0769 P ar ts list No. FRU FRU no. RoHS ID CRU ID 23 CPU assembly , Intel Celeron M pr ocessor 410 (1.46 GHz) 0689-65x, 66x, 67x, 68x, 69x 0768-65x, 66x, 67x, 68x, 82x • • 41W5181 R N CPU assembly , Intel Celer on M processor 420 (1.
Lenovo 3000 N100 and N200 125 P ar ts list No. FRU FRU no. RoHS ID CRU ID 23 CPU assembly , Intel Core Duo pr ocessor T2050 (1.60 GHz) 0689-85x 0768-85x • • 41W1461 R N CPU assembly , Intel Cor e Duo processor T2060 (1.
126 MT 0689, 0768, and 0769 P ar ts list No. FRU FRU no. RoHS ID CRU ID 23 CPU assembly , Intel Core 2 Duo pr ocessor T5500 (1.66 GHz) 0689-A4x, A5x, A6x, ACx, AHx, B3x, B4x, B5x, B6x, B9x, BBx, C7x, .
Lenovo 3000 N100 and N200 127 P ar ts list No. FRU FRU no. RoHS ID CRU ID 23 CPU assembly , Intel Core Duo Pr ocessor T2330 (1.6 GHz) 0769-ARx, BBx, BCx, BKx, BLx, AUx, A Vx, F5x, BUx, BYx, BZx, DNx • 43N7303 R D CPU assembly , Intel Cor e Duo Processor T2310 (1.
128 MT 0689, 0768, and 0769 P ar ts list No. FRU FRU no. RoHS ID CRU ID 24 Bluetooth daughter card (BDC) 0689-22x, 25x, 26x, 27x, 28x, 29x, 2Ax, 2Bx, 2Ex, 2Tx, 31x, 33x, 34x, 35x, 36x, 37x, 38x, 3Ax, .
LCD FRUs 1 2 3 4 7 5 6 14.1-in. WXGA TFT No. FRU FRU no. RoHS ID CRU ID 1 LCD front bezel, 14W without a camera v 0689-2xx, 3xx, 65x, 67x, 68x, 69x, 6Ax, 6Bx, 6Cx, 6Dx, 6Ex, 6Fx, 6Gx, 6Hx, 6Kx, 6Px, 6.
No. FRU FRU no. RoHS ID CRU ID 2 LCD panel, 14.1-in. WXGA anti-glare v 0689-31x, 33x, 37x, 38x, 39x, 3Ax, 3Bx, 3Cx, 3Dx, 3Fx, 3Jx, 3Lx, 3Mx, 41x,,42x, 43x, 44x, 52x, 5Jx, 67x, 68x, 69x, 6Ax, 6Hx, 6Jx,.
15.4-in. WXGA TFT No. FRU FRU no. RoHS ID CRU ID 1 LCD front bezel for MT 0768, 15W without a camera v 0768-2xx, 3xx, 4Jx, 4Mx, 4Px, 4Rx, 65x, 67x, 68x, 6Bx, 6Cx, 6Dx, 6Ex, 6Fx, 6Gx, 6Hx, 6Jx, 6Mx, 6S.
No. FRU FRU no. RoHS ID CRU ID 2 LCD panel, 15.4-in. WXGA glare, LPL v 0769-A7x, AAx, ABx, C5x, C6x, C7x, C8x, C9x, CAx, CBx, CDx, CGx, CHx, CJx, CKx, CNx, CPx, CQx, CRx, CUx, CVx, CWx, CYx, D2x, D4x,.
No. FRU FRU no. RoHS ID CRU ID 5 LCD rear cover , 15W (A cover) v 0768-all except CCx 41W5208 R N LCD rear cover , 15W (A cover) v 0768-CCx 41W6669 R N LCD rear cover with thr ee antennas v 0769-CWx, .
15.4-in. WSXGA+ TFT No. FRU FRU no. RoHS ID CRU ID 1 LCD front bezel for MT 0768, 15W (B cover) without a camera v 0768-21x, 22x, 25x, 26x, 27x, 28x, 2Cx, 6Kx, 6Lx, 6Nx, 6Px, 6Qx, 6Rx, 7Kx, 7Lx, 7Sx, .
No. FRU FRU no. RoHS ID CRU ID 3 Inverter card, 15W , Sumida v 0768-A2x, A3x, A4x, A5x, A6x, A7x, A8x, A9x, AAx, ABx, AJx, B2x, BEx, BFx, BHx, BJx, BKx, C6x, C7x, C8x, C9x, CAx, CBx, CDx, CEx, CHx, CK.
Keyboard Keyboard for MT 0689 and 0768 Language P/N (NMB) P/N (Chicony) RoHS ID CRU ID Arabic 39T7368 39T7432 R N Belgian 39T7365 39T7429 Chinese, T raditional 39T7379 39T7443 Czech 39T7373 39T7437 Danish 39T7362 39T7426 Dutch 39T7359 39T7423 English, U.
Keyboard for MT 0769 Language P/N (NMB) P/N (Chicony) RoHS ID CRU ID Arabic 42T3353 42T3418 R N Belgian 42T3350 42T3415 Chinese, T raditional 42T3364 42T3429 Czech 42T3358 42T3423 Danish 42T3347 42T3412 Dutch 42T3344 42T3409 English, U.K. 42T3342 42T3407 English, U.
Recovery discs Windows XP Professional CDs W indows XP Professional is pr einstalled as the operating system in the following models: v 0689-22x, 26x, 27x, 29x, 2Bx, 2Jx, 2Px, 33x, 34x, 36x, 38x, 3Ax,.
Parts list · 0769 ‐ AHx , AKx, D8 x Lang uage P/N RoHS ID CRU ID Arabic 44Y1149 R * Chinese, Simplified N/A Chinese, T raditional 44Y1143 Chinese, T raditional (Hong Kong S.A.R.) 44Y1144 Czech 44Y1148 Danish 44Y1138 Dutch 44Y1141 Englis h, U.
Windows XP Home Edition CDs W indows XP Home Edition is preinstalled as the operating system in the following models: v 0689-24x, 25x, 28x, 2Ax, 2Ex, 2Fx, 2Hx, 2Kx, 2Lx, 2Mx, 2Nx, 2Qx, 2Rx, 2Sx, 31x, .
Language P/N RoHS ID CRU ID Arabic 43T4481 R * Chinese, Simplified 43T4474 Chinese, T raditional 43T4475 Chinese, T raditional (Hong Kong S.A.R.) 43T4476 Czech 43T4480 Danish 43T4470 Dutch 43T4473 English, (UD) U.K. with disabled modem and WLAN 43T4463 English, U.
Windows V ista Home Premium (32 bit) DVDs for MT 0689 and 0768 W indows V ista Home Premium is pr einstalled as the operating system in the following models: v 0689-E3x, F5x, GAx, GBx, GCx, GDx, GFx, .
Windows V ista Home Premium (32 bit) DVDs for MT 0769 W indows V ista Home Premium is pr einstalled as the operating system in the following models: v 0769-AAx, ACx, ADx, B3x, C4x, C7x, C9x, CAx, CZx,.
Windows V ista Home Basic (32 bit) DVDs for MT 0689 and 0768 W indows V ista Home Basic is preinstalled as the operating system in the following models: v 0689-EAx, F2x, F3x, F8x, G3x, G8x, G9x, GGx, .
Windows V ista Home Basic (32 bit) DVDs for MT 0769 W indows V ista Home Basic is preinstalled as the operating system in the following models: v 0769-C8x, CBx, CEx, CGx, CJx, CLx, CNx, CQx, CUx, CXx, CYx, D2x, D6x, G5x Language P/N RoHS ID CRU ID Brazilian Portuguese 44X9804 R * Chinese, T raditional 44X9819 Chinese, T raditional (Hong Kong S.
Windows V ista Business (32 bit) DVDs for MT 0689 and 0768 W indows V ista Business is preinstalled as the operating system in the following models: v 0689-E2x, E4x, E5x, F4x, F7x, G4x, G7x, GEx, GNx,.
Windows V ista Business (32 bit) DVDs for MT 0769 W indows V ista Business is preinstalled as the operating system in the following models: v 0769-A7x, A8x, ABx, B2x, C3x, C5x, C6x, CDx, CFx, CHx, CKx.
Windows V ista Business (64 bit) DVDs W indows V ista Business is preinstalled as the operating system in the following models: v 0769-G4x Language P/N RoHS ID CRU ID Brazilian Portuguese 44X9855 R * Chinese, T raditional 44X9870 Chinese, T raditional (Hong Kong S.
Windows V ista Ultimate (32 bit) DVDs W indows V ista Ultimate is preinstalled as the operating system in the following models: v 0769-A9x, B4x, G2x Language P/N RoHS ID CRU ID Brazilian Portuguese 44X9830 R * Chinese, T raditional 44X9845 Chinese, T raditional (Hong Kong S.
Corel software CDs Language P/N RoHS ID CRU ID English, U.S. 41X0440 R * French 41X0443 Japanese 41X0608 Portuguese, Brazilian 41X0449 Spanish 41X0446 AC adapters FRU P/N RoHS ID CRU ID 2-pin (90 W, 2.
Power cords Power cords for MT 0689 and 0768 A Lenovo 3000 power cord for a specific country or r egion is usually available only in that country or region: For 2-pin power cords: Region P/N RoHS ID CRU ID Canada, U.
Power cords for MT 0769 A Lenovo 3000 power cord for a specific country or r egion is usually available only in that country or region: For 2-pin power cords: Region P/N (Longwell) P/N (V olex) RoHS ID CRU ID Argentina 42T5020 42T5105 R * Brazil 42T5026 42T51 1 1 Canada, U.
Miscellaneous parts FRU P/N RoHS ID CRU ID Screw kit for MT 0689 (including nylon-coated scr ews): v M2 × 3 mm (silver), flat head (9) v M2 × 4 mm (black), flat head (6) v M2 × 5 mm (silver), flat head (10) v M2.5 × 3 mm (black), flat head (18) v M2.
FRU P/N RoHS ID CRU ID Bottom miscellaneous parts for MT 0769: v RJ1 1 cable v Bluetooth cable v USB cable v TV -out cable v Speakers v USB EMI tape v Blank bezel for ExpressCar d slot v Rubber foot, .
Common parts list T ools T ool P/N T riconnector wrap plug 72X8546 Audio wrap cable 66G5180 USB parallel test cable 05K2580 Screwdriver kit 95F3598 Mini PC tool set 00P7033 1/4" drive spinner handle 1650840 1/4" Sq.
Notices Lenovo may not offer the pr oducts, services, or features discussed in this document in all countries. Consult your local Lenovo repr esentative for information on the products and services curr ently available in your area.
estimated through extrapolation. Actual r esults may vary . Users of this document should verify the applicable data for their specific environment. T rademarks The following terms are trademarks of L.
T rademarks Lenovo 3000 N100 and N200 157.
Part Number: 42X3553 (1P) P/N: 42X3553.
An important point after buying a device Lenovo N200 (or even before the purchase) is to read its user manual. We should do this for several simple reasons:
If you have not bought Lenovo N200 yet, this is a good time to familiarize yourself with the basic data on the product. First of all view first pages of the manual, you can find above. You should find there the most important technical data Lenovo N200 - thus you can check whether the hardware meets your expectations. When delving into next pages of the user manual, Lenovo N200 you will learn all the available features of the product, as well as information on its operation. The information that you get Lenovo N200 will certainly help you make a decision on the purchase.
If you already are a holder of Lenovo N200, but have not read the manual yet, you should do it for the reasons described above. You will learn then if you properly used the available features, and whether you have not made any mistakes, which can shorten the lifetime Lenovo N200.
However, one of the most important roles played by the user manual is to help in solving problems with Lenovo N200. Almost always you will find there Troubleshooting, which are the most frequently occurring failures and malfunctions of the device Lenovo N200 along with tips on how to solve them. Even if you fail to solve the problem, the manual will show you a further procedure – contact to the customer service center or the nearest service center
