Instruction/ maintenance manual of the product IRC 1195 Invacare
Go to page of 20
FREEW A Y LITE AEROSOL COMPRESSOR MODEL IRC 1 195 OWNER’S MANUAL.
2 SPECIAL NOTES SPECIAL NOTES W ARNING DO NOT install, maintain or operate this equipment without first reading and understanding this manual. If you are unable to understand the W ARNINGS and INSTRUCTIONS, contact your Home Healthcare Dealer before attempting to use this equipment - otherwise injury or damage may result.
3 T ABLE OF CONTENTS TABLE OF CONTENTS SPECIAL NOTES .............................................................................................. 2 T ABLE OF CONTENTS ..................................................................................
4 READ ALL INSTRUCTIONS BEFORE USING. When using electrical products, especially when children are present, basic safety precautions should always be followed, including the following: DANGER TO REDUCE THE RISK OF ELECTROCUTION: Always unplug this pr oduct IMMEDIA TEL Y after using.
5 Electrical Requirements: 90-240 V AC, 50-60Hz, or 12 -14 VDC Running Current: 2A @ 10 psig @ 12 volts (approximately) Ambient T emperature Range: 10 o C - 40 o C (50 o F - 104 o F) NOTE: Operating at temperature extremes may increase treatment times.
6 FREEWAY LITE When you unpack your Freeway Lite, you will notice that the battery pack, nebulizer kit, 12 volt DC lead, AC/DC power pack and power cord are separated from the main unit. The 12 volt DC lead, AC/DC power pack and power cord may be stored in the detach- able accessory bag.
7 Battery Pack Filter ON/OFF Switch Nebulizer Air T ubing Connection Power ON LOW Power Charging Battery Connectors Located Behind the Battery Pack NOTE: Rubber covers are installed on the battery connectors. Remove them before installing the battery pack.
8 FEATURES THE FREEWAY LITE AC/DC POWER PACK The Freeway Lite Power Pack is required for running the Freeway Lite from AC wall outlets and to recharge the batteries when not in use. Y our AC/DC Power Pack and cord are designed to operate from U.S. and North American outlet voltages and plug configurations (90 - 240 V AC, 50 - 60Hz).
9 INTRODUCTION Freeway Lite is different than other aerosol compressors because it is smaller , lighter and quieter . It has the added benefit of having batteries for complete portability . 1. Carefully unpack your Freeway Lite (keep the box as this may be required when returning it for servicing).
10 Normal Battery Charging Procedures 1. T urn the ON/OFF switch to the OFF position (position O). 2. If not already installed, attach the battery pack to the Freeway Lite. Connect the power pack or 12 volt DC lead to the DC power inlet on the Freeway Lite and connect the other end to a suitable power supply (wall or car outlet).
11 OPERA TION 2. Plug the power cord into the wall and the power pack outlet lead into the Freeway Lite DC inlet and the GREEN Charging indicator light will come ON.
12 OPERA TION CAUTION If the unit does NOT operate, IMMEDIA TEL Y disconnect the power supply from the DC inlet and check for correct polarity (Refer to SPECIFICA TIONS in this manual). NOTE: Battery alligator clips can be purchased from an electronics retail supply com- pany .
13 OPERA TION 3. Connect the long hose end of the coiled Duratube to the inlet on the bottom of the Sidestream. 4. Connect either the mouthpiece (supplied) or face mask (optional) to the Sidestream nebulizer . NOTE: Freeway Lite is designed to nebulize 2.
14 MAINTENANCE PROLONGING THE LIFE OF YOUR BATTERY The Freeway Lite ’ s battery is fully sealed and requires no maintenance. It should last for approximately 2000 treatments with normal use, but will last even longer if you follow these rules: 1. Fully discharge the battery at least once a month and fully charge again.
15 MAINTENANCE CLEANING THE OUTER CASE W ARNING UNPLUG unit before cleaning. DO NOT submerge in water to clean. Clean outer case with damp cloth. CARE OF YOUR FREEWAY LITE Y our Freeway Lite, battery pack and power pack can be cleaned by wiping with a damp cloth.
16 FIGURE 1 - CLEANING THE SIDESTREAM BASE MOUTHPIECE TOP CENTER BAFFLE JET HOLES 7. When all parts are thoroughly dry , store them in the storage compartment on the top of the Freeway Lite only .
17 REPLACING THE INTAKE FILTER NOTE: Change the filter as soon as it appears visibly dirty , this will be approximately every three (3) months. The time between filter changes varies according to the environmental conditions where the unit is used. For example, it will need to be changed more often in households where someone smokes.
18 SERVICING / TROUBLESHOOTING TROUBLESHOOTING PROBLEM POSSIBLE SOLUTIONS Unit does not run from battery . 1. Assure battery is installed properly . 2. Remove rubber bumpers. 3. Check all leads are removed from DC inlet. 4. Charge battery for 16 hours.
19 PLEASE NOTE: THE W ARRANTY BELOW HAS BEEN DRAFTED TO COMPL Y WITH FEDERAL LA W APPLICABLE TO PRODUCTS MANUF ACTURED AFTER JUL Y 4, 1975. This warranty is extended only to the original pur chaser/user of our products. This warranty gives you specific legal rights and you may also have other legal rights which vary from state to state.
INV ACARE CORPORA TION ONE INV ACARE W A Y Elyria, Ohio 44036 USA 800/333-6900 216/329-6000 Part No. 2001828 Form No. 94-157 Rev . C (2) - 8/99 Printed in USA.
An important point after buying a device Invacare IRC 1195 (or even before the purchase) is to read its user manual. We should do this for several simple reasons:
If you have not bought Invacare IRC 1195 yet, this is a good time to familiarize yourself with the basic data on the product. First of all view first pages of the manual, you can find above. You should find there the most important technical data Invacare IRC 1195 - thus you can check whether the hardware meets your expectations. When delving into next pages of the user manual, Invacare IRC 1195 you will learn all the available features of the product, as well as information on its operation. The information that you get Invacare IRC 1195 will certainly help you make a decision on the purchase.
If you already are a holder of Invacare IRC 1195, but have not read the manual yet, you should do it for the reasons described above. You will learn then if you properly used the available features, and whether you have not made any mistakes, which can shorten the lifetime Invacare IRC 1195.
However, one of the most important roles played by the user manual is to help in solving problems with Invacare IRC 1195. Almost always you will find there Troubleshooting, which are the most frequently occurring failures and malfunctions of the device Invacare IRC 1195 along with tips on how to solve them. Even if you fail to solve the problem, the manual will show you a further procedure – contact to the customer service center or the nearest service center
