Instruction/ maintenance manual of the product B-1500SS Hoshizaki
Go to page of 17
1 Hoshizaki “A Superior Degree of Reliability” www .hoshizaki.com Model B-1150SS B-1300SS B-1500SS B-1650SS Ice Bin Hoshizaki America, Inc. Issued: 2-15-2005 Revised: 8-28-200 6 I N S T R U C T I .
2 FOREW ORD IMPOR T ANT Only qualified ser vice technicians should attempt to install, ser vice or maintain this ice bin. No such installation, ser vice or maintenance should be under taken until the technician has thoroughly read this Instruction Manual.
3 • Please re vie w this manual. It should be read carefully bef ore the ice bin is installed and used. Only qualified ser vice technicians should install, ser vice and maintain the ice bin. This manual should be made a vailab le to the technician prior to installation, maintenance or ser vice.
4 I. Specifications A. Dimensions 1. B-1150SS units: mm [in.].
5 2. B-1300SS units: mm [in.].
6 3. B-1500SS units: mm [in.].
7 4. B-1650SS units: mm [in.].
8 II. Installation Instructions A. Checks Bef ore Installation IMPOR T ANT 1. This ice bin is designed and intended to be used in combination with a Hoshizaki Modular Icemaker .
9 C. Setup CA UTION It is especially impor tant that the ice bin is lev eled in both left-to-r ight and front- to-rear directions. If it is not le v el, the result could be the production of smaller or irregular shaped cubes or of ov erflow into the ice bin.
10 Single Icemaker Unit Dual Icemaker Units 2. Installing the Icemaker 1) Unpack the icemak er , and remov e all shipping car tons, tape(s) and pac kaging. 2) Ref er to the char ts below and also to the "SET UP" instructions on the icemaker when installing the icemaker .
11 Fig. 3 D . Drain Connections See Fig. 3 • A drain outlet, 1" f emale thread, is located on the bottom of the ice bin. • The drain must ha ve a 1/4" f all per foot on horizontal runs to get a good flow . • The ice bin drain connection must be made separ ately from the icemak er drains .
12 E. Final Check List 1) Is the icemaker/ice bin le v el? 2) Is the icemaker/ice bin in a site where the ambient temper ature is within +45°F to +100°F all year around? (A void sites with direct sunlight.
13 III. Operating Instructions See Fig. 4 A. Baffle The baffle pre v ents ice in the bin from flo wing out onto the floor while the bin door is open. 1. Remov al 1) Rotate the back edge of the baffle up about 6 inches (15 cm). 2) Pull the baffle f orw ard.
14 C. Probe (Optional Accessory) The probe is used to break apar t ice when it has br idged inside the bin and will not flow into the snout. T o break apar t ice, f ollow the steps below . 1) Open the bin door . 2) Inser t the probe through the hole in the snout (just abov e the baffle).
15 IV . Cleaning and Maintenance Instructions IMPOR T ANT Ensure all components, f asteners and thumbscrews are securely in place after any maintenance or cleaning is done to the equipment. A. Cleaning Instructions W ARNING 1. HOSHIZAKI recommends cleaning this unit at least once a year .
16 2. Sanitizing Procedure - Follo wing Cleaning Procedure 1) W ash all par ts cleaned in the cleaning procedure using the f ollowing sanitizing solution: 1/2 fl. oz. of a 5.25% sodium hypochlorite solution (chlorine bleach) diluted in 1 gallon of water .
17 HOSHIZAKI AMERICA, INC. 618 Hwy . 74 S., Peachtree City , GA 30269 USA TEL (770) 487-2331 F AX (770) 487-3360 www .hoshizaki.com 91A4LA10D.
An important point after buying a device Hoshizaki B-1500SS (or even before the purchase) is to read its user manual. We should do this for several simple reasons:
If you have not bought Hoshizaki B-1500SS yet, this is a good time to familiarize yourself with the basic data on the product. First of all view first pages of the manual, you can find above. You should find there the most important technical data Hoshizaki B-1500SS - thus you can check whether the hardware meets your expectations. When delving into next pages of the user manual, Hoshizaki B-1500SS you will learn all the available features of the product, as well as information on its operation. The information that you get Hoshizaki B-1500SS will certainly help you make a decision on the purchase.
If you already are a holder of Hoshizaki B-1500SS, but have not read the manual yet, you should do it for the reasons described above. You will learn then if you properly used the available features, and whether you have not made any mistakes, which can shorten the lifetime Hoshizaki B-1500SS.
However, one of the most important roles played by the user manual is to help in solving problems with Hoshizaki B-1500SS. Almost always you will find there Troubleshooting, which are the most frequently occurring failures and malfunctions of the device Hoshizaki B-1500SS along with tips on how to solve them. Even if you fail to solve the problem, the manual will show you a further procedure – contact to the customer service center or the nearest service center
