Instruction/ maintenance manual of the product HG5700 Homelite
Go to page of 24
ON OFF SA VE THIS MANUAL FOR FUTURE REFERENCE Y our generator has been engineer ed and manufactured to our high standard for dependability , ease of operation, and op- erator safety . When properly car ed for , it will give you years of rugged, trouble-free performance.
P age 2 — English DANGER: GROUNDING THE GENERA TOR T o reduce the risk of shock or electrocution, generator must be properly grounded. The nut and gr ound terminal on the frame must always be used to connect the generator to a suitable gr ound sour ce.
P age 3 — English IMPOR T ANT SAFETY INSTRUCTIONS DANGER: Carb on Mono xid e. Usin g a gene rat or indo ors WILL KILL YOU IN MINUTES. Generator exhaust contains high levels of carbon mon- oxide (CO), a poisonous gas you cannot see or smell. If you can smell the generator exhaust, you are breathing CO.
P age 4 — English SPECIFIC SAFETY RULES WARNING: When this generator is used to supply a building wiring system: generator must be installed by a quali- fied electrician and connected to a transfer switch as a separately derived system in accordance with NFP A 70, National Electrical Code.
P age 5 — English SYMBOLS Some of the following symbols may be used on this product. Please study them and lear n their meaning. Proper interpretation of these symbols will allow you to operate the pr oduct better and safer .
P age 6 — English DANGER: T o avoid death or serious personal injury , do not attempt to operate this product until you read thoroughly and understand completely the operator’ s manual. If you do not understand the war nings and instructions in the operator’ s manual, do not use this product.
P age 7 — English SYMBOLS SAFETY LABELS The information below can be found on the generator . For your safety , please study and understand all of the labels before starting the generator . If any of the labels come off the unit or become har d to read, contact an authorized service center for replacement.
P age 8 — English ELECTRICAL EXTENSION CORD CABLE SIZE Refer to the table below to ensur e the cable size of the extension cords you use ar e capable of carrying the r equired load. Inadequate size cables can cause a voltage drop, which can burn out the appliance and overheat the cord.
P age 9 — English ELECTRICAL GENERA TOR CAP ACITY Make sure the generator can supply eno ugh continuous (run- ning) and surge (starting) watts for the items you will power at the same time. Follow these simple steps. 1. Selecttheitemsyouwillpoweratthesametime.
P age 10 — English ON OFF PRODUCT SPECIFICA TIONS ENGINE Engine T ype .................................................. 4 Stroke, OHV Cooling System ................................................... Forced Air Starting System ....................
P age 11 — English KNOW YOUR GENERA TOR See Figure 1. The safe use of this pr oduct requ ir es an unders tand ing of the information on the product and in this operator’ s manual as wel l as a knowl edg e of the pr oje ct you are att emp tin g. Befo r e use of this product, familiarize yourself with all operating features and safety rules.
P age 12 — English LOOSE P ARTS LIST 1 Bolt (3/8-16 x 4-1/4 in.) .......................................2 2 W asher (3/8 in.) ....................................................6 3 Spacer (.38 ID) ...................................................
P age 13 — English ASSEMBL Y UNP ACKING This product requires assembly. Car efully cut the box down the sides then remove the machine and any accessories from the box. Make sure that all items listed in the packing list are included. NOTE: This machine is heavy and requir es a minimum of two people to lift.
P age 14 — English ASSEMBL Y Fig. 3 wheel sp acer wheel B ol t INST ALLING THE WHEELS See Figure 3. Wheels are pr ovided to assist in moving the generator to the desired location and should be installed on the side opposite the handle. Locate the following items: 2 bolts (3/8-16 x 4-1/4 in.
P age 15 — English OPERA TION DANGER: Failure to properly ground generator can r esult in elec- trocution, especially if the generator is equipped with a wheel kit. Nation al Electric Code re quir es generat or to be properly grounded to an appr oved earth ground.
P age 16 — English ON OFF recoil st arter grip Fig. 9 fUel v al ve Fig. 8 fUel t ank fUel cap OPERA TION CHECKING/ADDING FUEL See Figure 7. Remove the fuel cap. Fill the fuel tank to 1 in. below the top of the fuel neck. Replace and secure the fuel cap.
P age 17 — English Move choke lever left to rUn Move choke lever right to st art NOTE: Do not allow the grip to snap back after starting; return it gently to its original place. Allow the engine to run for 30 seconds, then move the choke lever left to the RUN position.
P age 18 — English 120/240V AC/CA 120V AC/CA Cord Retainer Cord Retainer 120V AC/CA CIRCUIT BREAKER DISYUNTOR Replace the element in the air filter unit. Replace the air filter cover and tighten screws to se- cure. NOTE: Do not run the generator without the air filter .
P age 19 — English MAINTENANCE CLEANING THE EXHAUST POR T AND MUFFLER Depending on the type of fuel used, the type and amount of lubricant used, and/or your operating conditions, the ex haust port and muffler may become blocked with carbon deposits.
P age 20 — English STORAGE When preparing the generator for storage, allow the unit to cool completely then follow the guidelines below . STORAGE TIME PRIOR TO STORING Less than 2 months Drain gasoline fr om tank and dispose of in a suitable container according to state and local or dinances.
P age 21 — English TROUBLESHOOTING PROBLEM POSSIBLE CAUSE SOLUTION Engine will not start. Engine switch is OFF . No fuel. Lubricant level is low . Fuel valve is OFF . Spark plug faulty , fouled, or impr operly gapped. Choke lever is in RUN position.
P age 22 — English W ARRANTY LIMITED W ARRANTY WARRANTY COVERAGE Homelite Consumer Pr oducts, Inc., (the Company) warrants to the original retail purchaser that this Homelite Product is free from de.
P age 23 — English Yamaha Motor Corporation USA Spark Ignited Small Off-Road Equipment (SORE) Limited and EPA Emissions Warranty Yamaha Motor Corporation, USA, hereby warrants that new Yamaha Spark .
5700 W A TT GENERA TOR Générateur de 5,700 watts Generador 5700 watts HG5700 Series Série HG5700 Serie HG5700 HOMELITE CONSUMER PRODUCTS, INC. 1428 Pearman Dairy Road, Anderson, SC 29625 1-800-242-4672 • www .
An important point after buying a device Homelite HG5700 (or even before the purchase) is to read its user manual. We should do this for several simple reasons:
If you have not bought Homelite HG5700 yet, this is a good time to familiarize yourself with the basic data on the product. First of all view first pages of the manual, you can find above. You should find there the most important technical data Homelite HG5700 - thus you can check whether the hardware meets your expectations. When delving into next pages of the user manual, Homelite HG5700 you will learn all the available features of the product, as well as information on its operation. The information that you get Homelite HG5700 will certainly help you make a decision on the purchase.
If you already are a holder of Homelite HG5700, but have not read the manual yet, you should do it for the reasons described above. You will learn then if you properly used the available features, and whether you have not made any mistakes, which can shorten the lifetime Homelite HG5700.
However, one of the most important roles played by the user manual is to help in solving problems with Homelite HG5700. Almost always you will find there Troubleshooting, which are the most frequently occurring failures and malfunctions of the device Homelite HG5700 along with tips on how to solve them. Even if you fail to solve the problem, the manual will show you a further procedure – contact to the customer service center or the nearest service center
