Instruction/ maintenance manual of the product 465-C1 Herrmidifier
Go to page of 12
Introduction ........................................1 Specifications ......................................1 Capacity Selection Guide ..................1 Installation Physical installation ......................2 Electrical Installation .............
T ype of Unit Rotating Drum Duct Mounting Return Supply GPD @ 140 ° F 22.5 17.1 GPD @ 120 ° F 16.5 12.4 GPD @ 100 ° F 10.6 7.8 V oltage 24V Unit Dimensions 14 3/4” W x 11” D x 11 1/2” H Duct .
2 Physical Installation Remember to select a location that is readily accessible for periodic inspection and cleaning of your humidifier . This unit should be located on the cold air return side of the system for best results. However , if space does not permit, it can be mounted on the warm air supply side of the system.
3 Physical Installation Installing Humidifier 1. Remove the window panel (panel with the label) by sliding it up, pulling its bottom away from the humidifier and then pulling down. 2. Separate the top half from the pan by sliding the stainless steel retainer off the lips of the top half and pan.
4 Humidifier Humidifier Humidifier Alternate location "A" coil Air cleaner Air cleaner Air cleaner Air cleaner Bypass duct Bypass duct Bypass duct Bypass duct Humidifier Humidifier 15.
5 Electrical Installation This humidifier is intended to be wired independently of the integrated control panel on your furnace. This will provide power to the humidifier at all times, causing the evaporator pad drum to rotate constantly .
6 Operation This 465-C1 humidifier operates on the silent principle of evaporation. When your unit is operating properly , you may observe the drum turning freely by looking through the observation window .
7 Maintenance Periodic cleaning is required for the efficient and safe operation of this humidifier . Inspect the humidifier approximately once a month for mineral and algae growth. Algae may develop inside the humidifier if certain conditions exist in the water supplying the unit.
8 Maintenance 6. Lift the drum shaft out of the support and slide the drum away from the motor , then down and away from unit. 7. Dump any accumulated sludge or slime from the pan. Clean thoroughly using a 50/50 solution of white vinegar and water or liquid humidifier cleaner .
9 21 20 2 7 1 3 8 9 10 11 12 13 14 18 16 17 15 4 19 23 22 6 5 Unit Diagram.
10 Model 465 C-1 Assembly Part Number 352440-001C Item Descripton P/N Remarks 1T op 1201BP 2 Motor 1322P 24V 50/60HZ 3 Float & valve assembly 1210P 4W asher FV -17 Fiber 5 Brass Locknut FV -10 7/1.
Wa rranty Humidifier Limited T wo Y ear W arranty This limited warranty covers Herrmidifier Residential T ype Humidifiers, excluding duct work, wiring and installation. The manufacturer warrants that all new Herrmidifier Humidifiers are free from defects in material and workmanship under normal, non-commercial use and service.
An important point after buying a device Herrmidifier 465-C1 (or even before the purchase) is to read its user manual. We should do this for several simple reasons:
If you have not bought Herrmidifier 465-C1 yet, this is a good time to familiarize yourself with the basic data on the product. First of all view first pages of the manual, you can find above. You should find there the most important technical data Herrmidifier 465-C1 - thus you can check whether the hardware meets your expectations. When delving into next pages of the user manual, Herrmidifier 465-C1 you will learn all the available features of the product, as well as information on its operation. The information that you get Herrmidifier 465-C1 will certainly help you make a decision on the purchase.
If you already are a holder of Herrmidifier 465-C1, but have not read the manual yet, you should do it for the reasons described above. You will learn then if you properly used the available features, and whether you have not made any mistakes, which can shorten the lifetime Herrmidifier 465-C1.
However, one of the most important roles played by the user manual is to help in solving problems with Herrmidifier 465-C1. Almost always you will find there Troubleshooting, which are the most frequently occurring failures and malfunctions of the device Herrmidifier 465-C1 along with tips on how to solve them. Even if you fail to solve the problem, the manual will show you a further procedure – contact to the customer service center or the nearest service center
