Instruction/ maintenance manual of the product Dakota 42H-B Heat & Glo LifeStyle
Go to page of 36
Heat & Glo LifeStyle Collection • Dakota 42-B/Dakota 42H-B • 4036-909 Rev C • 07/06 1 Owner ’ s Manual Installation and Operation Models: Dakota 42-B Dakota 42H-B DO NOT DISCARD THIS MANUAL CAUTION • Important operating and maintenance instructions included.
2 Heat & Glo LifeStyle Collection • Dakota 42-B/Dakota 42H-B • 4036-909 Rev C • 07/06 Read this manual before installing or operating this appliance.
Heat & Glo LifeStyle Collection • Dakota 42-B/Dakota 42H-B • 4036-909 Rev C • 07/06 3 T able of Contents 1 Listing and Code Approvals A. Appliance Certi fi cation . . . . . . . . . . . . . . . . . . . . . . . . . 4 B. Glass Speci fi cations .
4 Heat & Glo LifeStyle Collection • Dakota 42-B/Dakota 42H-B • 4036-909 Rev C • 07/06 1 1 Listing and Code Appro v als A. Appliance Certi fi cation This product is listed to ANSI standards .
Heat & Glo LifeStyle Collection • Dakota 42-B/Dakota 42H-B • 4036-909 Rev C • 07/06 5 A. Design and Installation Considerations Check building codes prior to installation. • Installation MUST comply with local, regional, state and national codes and regulations.
6 Heat & Glo LifeStyle Collection • Dakota 42-B/Dakota 42H-B • 4036-909 Rev C • 07/06 B A G E Note: If this surface is inside the building’s warm air envelope... ...then this surface must be an exterior wall system. C D F F C D G F E 57-3/4 in.
Heat & Glo LifeStyle Collection • Dakota 42-B/Dakota 42H-B • 4036-909 Rev C • 07/06 7 Fireplace Structure Mantel B A If A is: Then B must be at least: in. 6 - 36 26 mm 152 - 914 660 in. 36 or more 18 mm 914 or more 4 5 7 84 in. (2134 mm) minimum height Addi tio nal Structure or Sidewall Roof or Overhang 12 in.
8 Heat & Glo LifeStyle Collection • Dakota 42-B/Dakota 42H-B • 4036-909 Rev C • 07/06 FP = FIREPLACE OPENING X = AIR SUPP L Y INLE T = AREA WHERE FIREPLACE IS NOT PERMITTED O N P R Q FP (See.
Heat & Glo LifeStyle Collection • Dakota 42-B/Dakota 42H-B • 4036-909 Rev C • 07/06 9 5 5 Appliance Preparation Sharp Edges • Wear protective gloves and safety glasses during installation. CAUTION A. Remove Logs and Shipping Cover Open the doors by sliding the handles toward the outside edges of the doors (see Figure 5.
10 Heat & Glo LifeStyle Collection • Dakota 42-B/Dakota 42H-B • 4036-909 Rev C • 07/06 A. Fuel Conversion Before making gas connections ensure appliance being in- stalled is compatible with the available gas type.
Heat & Glo LifeStyle Collection • Dakota 42-B/Dakota 42H-B • 4036-909 Rev C • 07/06 1 1 W ARNING Fire Risk Explosion Risk • Gas build-up during line purge may ignite. • Purge should be performed by quali fi ed technician. • Ensure adequate ventilation.
12 Heat & Glo LifeStyle Collection • Dakota 42-B/Dakota 42H-B • 4036-909 Rev C • 07/06 E. V alve Access W asher Figure 6.1 Lift Out Doors Figure 6.3 Loosen Refractory Retaining Strip Figure 6.4 Remove V alve Access Panel Figure 6.5 Remove Exterior V alve Access Panel Figure 6.
Heat & Glo LifeStyle Collection • Dakota 42-B/Dakota 42H-B • 4036-909 Rev C • 07/06 13 Batt er y po l a r i t y m us t b e c o r rec t o r m o dul e da m a g e w i l l occur .
14 Heat & Glo LifeStyle Collection • Dakota 42-B/Dakota 42H-B • 4036-909 Rev C • 07/06 A. Mantel Projections Figure 8.1 shows the minimum vertical dimension of appliance mantels or other combustible projections above the top front edge of the appliance.
Heat & Glo LifeStyle Collection • Dakota 42-B/Dakota 42H-B • 4036-909 Rev C • 07/06 15 Sealant Material 0 in. 0 in. 0 in. Upper front can be covered with non-combustible material or removed and replaced with non- combustible material. Finish wall material may be combustible, top & sides.
16 Heat & Glo LifeStyle Collection • Dakota 42-B/Dakota 42H-B • 4036-909 Rev C • 07/06 A. Clean the Appliance Clean/vacuum any sawdust that may have accumulated in- side the fi rebox or underneath in the control cavity . Shock Risk Fire Risk Use ONL Y optional accessories approved for this appliance.
Heat & Glo LifeStyle Collection • Dakota 42-B/Dakota 42H-B • 4036-909 Rev C • 07/06 17 Figure 9.6 Front Left Log (SRV722) • Place front left log between locating bars so it rests against log left side log and on top of front log. Figure 9.
18 Heat & Glo LifeStyle Collection • Dakota 42-B/Dakota 42H-B • 4036-909 Rev C • 07/06 Handle glass with care. • Inspect the glass for cracks, chips or scratches. • Do NOT strike, slam or scratch glass. • Do NOT operate appliance with glass door removed, cracked, broken or scratched.
Heat & Glo LifeStyle Collection • Dakota 42-B/Dakota 42H-B • 4036-909 Rev C • 07/06 19 Fire Risk Burn Risk HOT! DO NOT TOUCH. SEVERE BURNS MA Y RESUL T . CLOTHING IGNITION MA Y RESUL T Glass and other surfaces are hot during operation and cool down.
20 Heat & Glo LifeStyle Collection • Dakota 42-B/Dakota 42H-B • 4036-909 Rev C • 07/06 B. Lighting the Appliance Intelli fi re Ignition Final Inspection by _________________________________ 1. T urn off wall switch. 2. This appliance is equipped with an igni- tion device which automatically lights the burner .
Heat & Glo LifeStyle Collection • Dakota 42-B/Dakota 42H-B • 4036-909 Rev C • 07/06 21 Note: This applianc e should be run three to four hour s on the initial star t-up. T ur n it of f and let it co ol co mpletely . Remove and clean the glass.
22 Heat & Glo LifeStyle Collection • Dakota 42-B/Dakota 42H-B • 4036-909 Rev C • 07/06 With proper installation, operation and maintenance your gas appliance will provide years of trouble-free service.
Heat & Glo LifeStyle Collection • Dakota 42-B/Dakota 42H-B • 4036-909 Rev C • 07/06 23 Although the frequency of appliance servicing and maintenance will depend on use and the type of installation, a quali fi ed service technician should perform an appliance check-up at the beginning of each heating season.
24 Heat & Glo LifeStyle Collection • Dakota 42-B/Dakota 42H-B • 4036-909 Rev C • 07/06 A. V alve Service and Replacement Figure 12.3 Loosen Refractory Retaining Strip Figure 12.2 Lift Out Doors Figure 12.4 Remove V alve Access Panel Figure 12.
Heat & Glo LifeStyle Collection • Dakota 42-B/Dakota 42H-B • 4036-909 Rev C • 07/06 25 Ground Wire Figure 12.8 Remove V alve from V alve Bracket • Using two 3/4 in. wrenches, disconnect the burner supply tube. • Remove the two screws securing the valve to the valve bracket.
26 Heat & Glo LifeStyle Collection • Dakota 42-B/Dakota 42H-B • 4036-909 Rev C • 07/06 B. Maintenance and Service T asks: Inspect Maintenance T asks Doors, surrounds and fronts 1. Inspect for scratches and nicks that can lead to breakage when exposed to heat.
Heat & Glo LifeStyle Collection • Dakota 42-B/Dakota 42H-B • 4036-909 Rev C • 07/06 27 A. Appliance Dimension Diagram Dimensions are actual appliance dimensions. Use for reference only . For framing dimensions and clearances refer to Sec- tion 3.
28 Heat & Glo LifeStyle Collection • Dakota 42-B/Dakota 42H-B • 4036-909 Rev C • 07/06 B. Service Parts List Exploded Parts Diagram 42 in. Outdoor Gas Fireplace Service Parts DAKOT A42-B SER.
Heat & Glo LifeStyle Collection • Dakota 42-B/Dakota 42H-B • 4036-909 Rev C • 07/06 29 Service Parts List 42 in. Outdoor Gas Fireplace (parts listed in bold italics are critical parts) Servi.
30 Heat & Glo LifeStyle Collection • Dakota 42-B/Dakota 42H-B • 4036-909 Rev C • 07/06 Exploded Parts Diagram 42 in. Outdoor Gas Fireplace Service Parts DAKOT A42-B SERIES Beginning Manufact.
Heat & Glo LifeStyle Collection • Dakota 42-B/Dakota 42H-B • 4036-909 Rev C • 07/06 31 Service Parts List 42 in. Outdoor Gas Fireplace (parts listed in bold italics are critical parts) Servi.
32 Heat & Glo LifeStyle Collection • Dakota 42-B/Dakota 42H-B • 4036-909 Rev C • 07/06 Service Parts List 42 in. Outdoor Gas Fireplace Service Parts DAKOT A42-B SERIES Beginning Manufacturin.
Heat & Glo LifeStyle Collection • Dakota 42-B/Dakota 42H-B • 4036-909 Rev C • 07/06 33 # Description of Part DAKOT A42-B DAKOT A42H-B DAKOT A42L-B DAKOT A42LH-B Qty .
34 Heat & Glo LifeStyle Collection • Dakota 42-B/Dakota 42H-B • 4036-909 Rev C • 07/06 This page intentionally left blank..
Heat & Glo LifeStyle Collection • Dakota 42-B/Dakota 42H-B • 4036-909 Rev C • 07/06 35 C. W arranty W ARRANTY FOR HEA T & GLO LIFESTYLE COLLECTION FIREPLACES The limited warranty will not become effective until you have mailed the completed warranty card to: Hearth & Home T echnologies Inc.
36 Heat & Glo LifeStyle Collection • Dakota 42-B/Dakota 42H-B • 4036-909 Rev C • 07/06 D. Contact Information Please contact your Heat & Glo LifeStyle Collection dealer with any questions or concerns.
An important point after buying a device Heat & Glo LifeStyle Dakota 42H-B (or even before the purchase) is to read its user manual. We should do this for several simple reasons:
If you have not bought Heat & Glo LifeStyle Dakota 42H-B yet, this is a good time to familiarize yourself with the basic data on the product. First of all view first pages of the manual, you can find above. You should find there the most important technical data Heat & Glo LifeStyle Dakota 42H-B - thus you can check whether the hardware meets your expectations. When delving into next pages of the user manual, Heat & Glo LifeStyle Dakota 42H-B you will learn all the available features of the product, as well as information on its operation. The information that you get Heat & Glo LifeStyle Dakota 42H-B will certainly help you make a decision on the purchase.
If you already are a holder of Heat & Glo LifeStyle Dakota 42H-B, but have not read the manual yet, you should do it for the reasons described above. You will learn then if you properly used the available features, and whether you have not made any mistakes, which can shorten the lifetime Heat & Glo LifeStyle Dakota 42H-B.
However, one of the most important roles played by the user manual is to help in solving problems with Heat & Glo LifeStyle Dakota 42H-B. Almost always you will find there Troubleshooting, which are the most frequently occurring failures and malfunctions of the device Heat & Glo LifeStyle Dakota 42H-B along with tips on how to solve them. Even if you fail to solve the problem, the manual will show you a further procedure – contact to the customer service center or the nearest service center
