Instruction/ maintenance manual of the product FAW-40-1SPP Empire Products
Go to page of 36
12427-4-0306 Page 1 INST ALLA TION INSTRUCTIONS AND OWNER'S MANUAL F AN TYPE VENTED W ALL FURNACE MODEL F A W -40-1SPP F A W -40-1IP EFFECTIVE DA TE MARCH 2006 W ARNING: If the information in this manual is not followed exactly , a fir e or explosion may result causing property damage, personal injury or loss of life.
12427-4-0306 Page 2 The base referred to above does not mean the fire-proof base as used on wood stoves. The protection is for rugs that are extremely thick and light colored tile.
12427-4-0306 Page 3 Some people cannot smell well. Some people cannot smell the odor of the chemical stench put into the gas. Y ou must find out if you can smell the odorant in propane. Smoking can decrease your ability to smell. Being around an odor for a time can affect your sensitivity or ability to detect that odor .
12427-4-0306 Page 4 Figure 1 Outdoor Air Outlet and inlet air can be brought into the confined space via openings into a ventilated attic and ventilated crawl space.
12427-4-0306 Page 5 C. 4" (102mm) Oval In-The-W all (all parts purchase locally) 1. T ype B-1 oval pipe or B-W vent pipe 2. T ype B-1 oval elbows or B-W oval elbows 3. Single story type B-1 or (B-W) gas vents require a baseplate and one pair of ceiling plate spacers.
12427-4-0306 Page 6 Figure 5 Use U.L. listed gas vent equipment when installing the F A W -40. For vent pipe running through walls, roof, and within one (1) inch (25mm) of combustible construction, use B-1 or (B-W) [one inch (25mm) clearance to combustibles] vent pipe.
12427-4-0306 Page 7 #8 x 3/8" (9mm) screws provided. 8. Align clearance holes on 6" x 10" (152mm x 254mm) duct with screw holes on inner casing back and mark duct to be 2 1/4" (57mm) shorter than 8" x 12" (203mm x 305mm) boot.
12427-4-0306 Page 8 Attention! If one of the above procedures results in pressures in excess of 1/2 psig (14" w .c.) (3.5 kPa) on the appliance gas valve, it will result in a hazardous condition. Checking Manifold Pressur e Both Propane and Natural gas valves have a built-in pressure regulator in the gas valve.
12427-4-0306 Page 9 Oiling the Motor The fan motor should be cleaned and oiled once each heating season. Oil holes are located on the top at each end of the motor . Use a few drops of #10 motor oil. T o clean the motor , blow air through its ventilation openings with a vacuum cleaner or low pressure air source.
12427-4-0306 Page 10 SER VICE AND MAINTENANCE SUGGESTIONS CALL SER VICEMAN GENERAL: All furnaces have been fire-tested to check for proper op- eration. This includes, main burner flame, pilot flame, fan operation, fan control, limit control and automatic valve operation.
12427-4-0306 Page 1 1 FOR YOUR SAFETY READ BEFORE LIGHTING W ARNING: If you do not follow these instructions exactly , a fire or explosion may result causing property damage, personal injury or loss of life. A. This appliance has a pilot which must be lighted by hand.
12427-4-0306 Page 12 FOR YOUR SAFETY READ BEFORE OPERA TING W ARNING: If you do not follow these instructions exactly , a fire or explosion may result causing property damage, personal injury or loss of life. A. This appliance is equipp ed with an ignition device which automatically lights the pilot.
12427-4-0306 Page 13 ST AR T System Check T rial for Ignition Main Burner Operation END Pilot V alve Opens Ignitor Powered Flame Signal Detected Thermostat Calls for Heat Ignitor OFF M.
12427-4-0306 Page 14 ST AR T IP SYSTEM TROUBLESHOOTING SEQUENCE T urn OFF Gas Supply Disconnect System Control Harness Set Thermostat to Call for Heat Check for Proper V oltage at Control Harness (See Inset A - V o l t a g e S h o u l d b e 2 4 V Between Thermostat and 24V Common, and 24V Between 24V Common and 24V Hot.
12427-4-0306 Page 15 I N D EX P AR T N O. N U M BE R D ES CR I P T I O N I N D EX P AR T N O. N U M BE R D E S CR IP T I O N PLEASE NOTE: When ordering parts, it is very important that part number and description of part coincide.
12427-4-0306 Page 16.
12427-4-0306 Page 17 Service Notes.
12427-4-0306 Page 18 Empire Comfort Systems, Inc. Nine Eighteen Freeburg A ve. Belleville, Illinois 62220-2623 PH: 1-618-233-7420 PH: 1-800-851-3153 F AX: 1-618-233-7097 F AX: 1-800-443-8648 E-MAIL: info@empirecomfort.com WEB SITE: www .empirecomfort.
12427(F)-3-0903 Page 1 INSTRUCTIONS POUR L ’INST ALLA TION ET MANUEL DU PROPRIÉT AIRE RADIA TEUR MURAL À CIRCULA TION FORCÉE ET A VEC ÉV ACUA TION MODÈLE F A W -40-1SPP F A W -40-1IP DA TE D’.
12427(F)-3-0903 Page 2 La base que nous décrivons ci-dessus ne signifie pas le genre de base contre le feu comme il est utilisé pour les poêles à bois. La protection est pour les tapis extrêmement épais et les tuiles de couleur qui pourraient se décolorer .
12427(F)-3-0903 Page 3 INFORMA TION DE SÉCURITÉ POUR LES UTILISA TEURS DE PROP ANE Le propane est un gaz inflammable qui peut causer des feux et des explosions.
12427(F)-3-0903 Page 4 A TTENTION: L ’air de combustion ne doit pas provenir d’un espace chauffé lequel inclus des ventilateurs soufflants, foyers ou d’autres appareils qui peuvent produire une pression négative dans l’espace.
12427(F)-3-0903 Page 5 Figure 4 B. Ovale de 4" (102mm) (toutes les pièces peuvent être achetées localement) 1. T uyau ovale de type B-1 ou tuyau d’évacuation B-W . 2. Les évents à gaz de type B-1 ou (B-W) pour un étage exige une plaque de base et une paire d’entretoises pour la plaque du plafond.
12427(F)-3-0903 Page 6 Pour installer le SOK-1, s’il vous plaît utilisé les étapes 1 jusqu’à 5 dans les instructi ons du SOR-1 pour les radiateu rs F A W -40. Maintenant, utiliser les étapes suivantes pour compléter l’installation du SOK-1.
12427(F)-3-0903 Page 7 arrière pour former un carré. Percer un trou pilote à l’intérieur du carré que vous avez tracé sur la paroi extérieure arrière. Enlever la feuille de métal à l’intérieur du carré que vous avez tracé, avec des ciseaux à métal ou un outil comparable.
12427(F)-3-0903 Page 8 Figure 8 M é t h o d e p o u r i n s t a l l e r u n c o l l e c t e u r d e s é d i m e n t a v e c u n a d a p t e u r e n T L ’emploi des connexions de gaz suivantes est recommandé. — ANS Z21.24 Connexions d’appareil de tuyaux et de raccords en métal ondulé.
12427(F)-3-0903 Page 9 L ’Enceinte de l’Évent Isolée Les radiateurs muraux avec un évent, installés dans des bâtiments ayant un toit plat, peuvent avoir une évacuation inadéquate.
12427(F)-3-0903 Page 10 Figure 13 Figure 14 SUGGESTIONS POUR LE SER VICE ET L ’ENTRETIEN. Appeler un technicien d’entr etien. Général : T ous les radiateurs ont reçu un test d’allumage pour vérifier le bon fonctionnement.
12427(F)-3-0903 Page 1 1 V eilleuse modèle IP Ce radiateur utilise un système “Smart V alve” Honeywell pour l’allumage intermittent de la veilleuse.
12427(F)-3-0903 Page 12 1. Arrêter! Lire les informations de sécurité ci-dessus. 2. Mettre le thermostat à son plus bas réglage. 3. Éteindre tout pouvoir électrique à l’appar eil. 4. Enlever le panneau d’accès au contrôle (panneau du bas avant).
12427(F)-3-0903 Page 13 1. Arrêter! Lire les informations de sécurité ci-dessus. 2. Mettre le thermostat à son plus bas réglage. 3. Éteindre tout pouvoir électrique à l’appareil. 4. Cet appareil est muni d’un dispositif d’allumage lequel allume automatiquement la veilleuse.
12427(F)-3-0903 Page 14.
12427(F)-3-0903 Page 15.
12427(F)-3-0903 Page 16 I n d ex P a r t N o. N u m be r De sc r i p t io n I n d ex P a r t N o. N u m be r De s c r i pt io n PLEASE NOTE: When ordering parts, it is very important that part number and description of part coincide.
12427(F)-3-0903 Page 17 Empire Comfort Systems, Inc. Nine Eighteen Freebur g A ve. Belleville, Illinois 62222-0529 VEILLEUSE ET SUP- POR T POUR LES MODÉ - LES SPP.
12427(F)-3-0903 Page 18 Empire Comfort Systems, Inc. Nine Eighteen Freeburg A ve. Belleville, Illinois 62220-2623 PH: 1-618-233-7420 PH: 1-800-851-3153 F AX: 1-618-233-7097 F AX: 1-800-443-8648 E-MAIL: info@empirecomfort.com WEB SITE: www .empirecomfort.
An important point after buying a device Empire Products FAW-40-1SPP (or even before the purchase) is to read its user manual. We should do this for several simple reasons:
If you have not bought Empire Products FAW-40-1SPP yet, this is a good time to familiarize yourself with the basic data on the product. First of all view first pages of the manual, you can find above. You should find there the most important technical data Empire Products FAW-40-1SPP - thus you can check whether the hardware meets your expectations. When delving into next pages of the user manual, Empire Products FAW-40-1SPP you will learn all the available features of the product, as well as information on its operation. The information that you get Empire Products FAW-40-1SPP will certainly help you make a decision on the purchase.
If you already are a holder of Empire Products FAW-40-1SPP, but have not read the manual yet, you should do it for the reasons described above. You will learn then if you properly used the available features, and whether you have not made any mistakes, which can shorten the lifetime Empire Products FAW-40-1SPP.
However, one of the most important roles played by the user manual is to help in solving problems with Empire Products FAW-40-1SPP. Almost always you will find there Troubleshooting, which are the most frequently occurring failures and malfunctions of the device Empire Products FAW-40-1SPP along with tips on how to solve them. Even if you fail to solve the problem, the manual will show you a further procedure – contact to the customer service center or the nearest service center
