Instruction/ maintenance manual of the product CHG Empire Comfort Systems
Go to page of 12
CHG/CHR Page 1 OUTDOOR GAS FIREPLACE MODELS CHR-2 CHG-2 EFFECTIVE DA TE JUNE, 2001 INST ALLA TION INSTRUCTIONS AND OWNER'S MANUAL WARNING: If the information in this manual is not followed exactly, a fire or explosion may result causing property damage, personal in- jury or loss of life.
Page 2 CHG/CHR • Read instructions before lighting. • If ignition does not immediately take place, turn the gas control knob to OFF, wait 5 minutes, and repeat the lighting procedure. • Certain materials or items, when stored under the outdoor gas fireplace, will be subjected to radiant heat and could be seri- ously damaged.
CHG/CHR Page 3 AVERTISSEMENTS POUR LE CONSOMMATEUR: • Savoir reconnaître l’odeur du gaz PL. Si vous entendez un sifflement ou si vous sentez une odeur de gaz PL, éloignez immédiatement toutes les personnes qui sont près de la bouteille et appelez le service d’incendie.
Page 4 CHG/CHR OVERFILL PROTECTION DEVICE (OPD) ON 20 LB. PROPANE CYLINDER Attention: Consumer be advised, this outdoor gas fireplace must be connected to an LP gas cylinder incorporating an OPD. The OPD will help reduce the potential for the overfilling of the propane cylinder, thus reducing the possibility of hydrostatic relief valve discharges.
CHG/CHR Page 5 Figure 2 Figure 3 CLEARANCES Minimum Clearances From Combustible Construction (Figures 2 and 3) Side 6" Rear 6" Top 47" from top of unit or 96" from floor Floor Combustible Minimum Clearances From Combustible Construction with 20 lb.
Page 6 CHG/CHR 1. Remove packing material from top of box. 2. Lift chimney section out and set aside. 3. Remove remaining items and packing from inside outdoor gas fireplace firebox. 4. Lift firebox out of box and sit on flat surface near desired final location.
CHG/CHR Page 7 Figure 8 10. Place the hold-down bar under the flicker shield. Push the flicker shield and hold-down bar up to the bottom of the outdoor gas fireplace. Figure 9 11. Insert the 4 5/8" hold down bolt through the hole in hold down bar and flicker shield and rear burner cross support.
Page 8 CHG/CHR Figure 12 Figure 12 GAS CONVERSION INSTRUCTIONS Warning: Conversion must be done by a qualified service technician. Conversion Instructions from Propane (LP) gas to Natural gas. 1. If installed, turn off gas supply to outdoor gas fireplace.
CHG/CHR Page 9 LEAK TESTING WARNING! Before lighting your outdoor gas fireplace be sure to read this section carefully. Turn gas valve knob to the OFF position. Inspect the gas supply piping or hose prior to turning the gas ON. If there is evidence of cuts, wear, or abrasion, it must be replaced prior to use.
Page 10 CHG/CHR ADJUSTING FOR PROPER FLAME Air Shutter (Figure 13) Each burner is tested and adjusted at the factory prior to shipment. However, variations in the local gas supply may make it necessary to adjust the burner. The flames of the burner should be visually checked.
CHG/CHR Page 11 1. Fireplace won't light when the piezo ignitor is depressed. a. With the gas tuned off depress the piezo ignitor to check the spark. You should see a spark jump from tip of the electrode. If there is a spark, check the gas supply.
Page 12 CHG/CHR HOW TO ORDER REPAIR PARTS ... All parts listed in the Parts List have a Part Number When ordering parts, first obtain the Model Number from the nameplate on your equipment. Then determine the Part Number (not the Index Number) and the Description of each part from the appropriate illustration and list.
An important point after buying a device Empire Comfort Systems CHG (or even before the purchase) is to read its user manual. We should do this for several simple reasons:
If you have not bought Empire Comfort Systems CHG yet, this is a good time to familiarize yourself with the basic data on the product. First of all view first pages of the manual, you can find above. You should find there the most important technical data Empire Comfort Systems CHG - thus you can check whether the hardware meets your expectations. When delving into next pages of the user manual, Empire Comfort Systems CHG you will learn all the available features of the product, as well as information on its operation. The information that you get Empire Comfort Systems CHG will certainly help you make a decision on the purchase.
If you already are a holder of Empire Comfort Systems CHG, but have not read the manual yet, you should do it for the reasons described above. You will learn then if you properly used the available features, and whether you have not made any mistakes, which can shorten the lifetime Empire Comfort Systems CHG.
However, one of the most important roles played by the user manual is to help in solving problems with Empire Comfort Systems CHG. Almost always you will find there Troubleshooting, which are the most frequently occurring failures and malfunctions of the device Empire Comfort Systems CHG along with tips on how to solve them. Even if you fail to solve the problem, the manual will show you a further procedure – contact to the customer service center or the nearest service center
