Instruction/ maintenance manual of the product RM182B Dometic
Go to page of 18
B)TDometic SERVICE United States SERVICE OFFICE DOMETIC SALES CORP 509 South Poplar LaGrange, IN 46761 SERVICE MANUAL REFRIGERATOR RM182 B Edition 2 August 1982 DSC #651 Whe n ordering spare parts always state: MODEL.
TABLE OF CONTENTS A. B. c. D. E. F. G. H. Installation Instructions Instructions For Use RM 182B General Instructions Sealed Combustion Unit Ventilator (improved cooling performance) Fuse - 12 Volt Ci.
A. INSTALLAT IO N INSTRUCT IONS The design of this refrigerator has been certified and approved by the American Gas Association and the Canadia n GAS Association for Recreational Vehicles. This certification is dependent , however upon proper installation’-and the use of the venting components as shown in these instructions.
B. INSTRUCTIONS FOR USE R M 18 2 B The Control s : Controls are located at the top of the refrigerator. 1. Control Pane l : Fig. 1 Page 1 ___ “A” - "B" - "C" _ Air Pump and Pie.
General Instructions Sealed Combustion Unit The sealed canbustion unit is made up of the burner, a fresh air intake and exhaust pipes, and a vent/air-intake assembly in the wall. The burner unit is completely seale d off’ from the interior of the van by means of the two special inlet and outlet pipes .
C. REMOVAL AND INSTALLATION OF REFRIGERATOR Remova 1 1. 2. 3. 4. 5. 6. 7. Disconnect electrical supply. And make sure the its source. Remove the vent /air-intake assembly on the van a. Unscrew three self-tapping screw s (A,Fig.2) then remove windscreen and separating plate b.
D. COMPONENT REPLACEMEN T RM 182B NOTE: For the removal of gas and electrical components and of the refrigerator cooling unit, the refrigerator must be removed from the kitchen cabinet (see chapter C ) . 1. Replacing the electric heater _____ 1. Squeeze the heater insulation in direction of arrow (A,Fig.
4. 5. 6. 7. 8. 9. 10. 11. 12. 13. Pull off thermosta t knob (C , Fig.11) and knob (D , Fig.11) of safety device (E, Fig. 11). Unscrew union nut (F , Fig.11) of gas-pipe (G, Fig.11) from flame failure safety device (E, Fig. 11). Remove three cable plug-connections from thermostat (H , Fig.
8 . Replacing the burner-je t ( E Fig . 12) __ _ ____ 1. Unscrew union nut (F, Fig. 12) of gas pipe by using a lo mm fork-spanner and a second one (1 4 mm) to hold counterpart the jet. 2. Unscrew burner jet from the bottom part of gas-burner. 3. Screw in the new burner jet, refit gas pipe.
lo. Removing the ai r pump and replacing the piston. __________ _ _ _ _____ _____ 1. Unscrew knob (A, Fig.9) of air pump (K, Fig.9) from the shaf t (L, Fig.9). 2. Unscrew air pump ( 4 screw s / M, Fig. 9). 3. Unscrew cover of air-pump ( 2 screw s / N, Fig.
F. TROUBLESHOOTING THE REFRIGERATO R - L.P. GAS SYMPTOM - - - - - - - - - - - - - - - - Y - - - CAUSE NOTE: It will be noted in this guide that several causes ca n be responsible for one effect .
G. TROUBLESHOOTING THE REFRIGERATO R - ELECTRIC SYMPTOM CAUSE NOTE: It will be noted i n this guide that several causes can be responsible for one effect . The rea l cause or causes shoul d be determined by the process of elimination, investigating each possible cause, star- ting at the top of the guide and proceeding to the bottom.
A 8 c 13 E /-- 0 I @I Fig. 1 Fig. 3 /- 0 C I A' Fig. 4 Fig. 2 Fig. 6 Fig. 5 -12 -.
I I I I I I I I I ,I I .I I I I .I ,I , I .I ‘I I I A; I -1 I I ‘I I I .I I .I .I I .I *I I I I 1 I I Fig. 7 it-- il 11 II II II II I II II II II II II II IllI ’ I I II I! II II II ll II II 11 .
E D c B A - f-l . a f 1 ,, t-+ I * 1 L1--r’ 1, L-J R 1 1 I.1 R I n h n Fig. 9.
. % i C D - f-l I 1, I Fig.11 - 15-.
L --. ,,-,--I_ t:i __) F /- E /- Q Fig.12 -16 -.
Fig.14 . . I ’ ’ II rl t -- - Fig.15 -17-.
An important point after buying a device Dometic RM182B (or even before the purchase) is to read its user manual. We should do this for several simple reasons:
If you have not bought Dometic RM182B yet, this is a good time to familiarize yourself with the basic data on the product. First of all view first pages of the manual, you can find above. You should find there the most important technical data Dometic RM182B - thus you can check whether the hardware meets your expectations. When delving into next pages of the user manual, Dometic RM182B you will learn all the available features of the product, as well as information on its operation. The information that you get Dometic RM182B will certainly help you make a decision on the purchase.
If you already are a holder of Dometic RM182B, but have not read the manual yet, you should do it for the reasons described above. You will learn then if you properly used the available features, and whether you have not made any mistakes, which can shorten the lifetime Dometic RM182B.
However, one of the most important roles played by the user manual is to help in solving problems with Dometic RM182B. Almost always you will find there Troubleshooting, which are the most frequently occurring failures and malfunctions of the device Dometic RM182B along with tips on how to solve them. Even if you fail to solve the problem, the manual will show you a further procedure – contact to the customer service center or the nearest service center
