Instruction/ maintenance manual of the product MSRBVP Desa
Go to page of 32
CAST IRON STOVE AND B-VENT (FREEST ANDING FIREPLACE HEA TER) BURNER SYSTEM OWNER’S OPERA TION AND INST ALLA TION MANUAL NA TURAL GAS BURNER SYSTEM MODEL MSRBVN PROP ANE/LP GAS BURNER SYSTEM MODEL MSRBVP REMOTE READY Save this manual for future reference.
2 CAST IRON STOVE AND BURNER SYSTEM 106706 SUN V ALLEY STOVE COMP ANY For more information, visit www.desatech.com SAFETY INFORMA TION 1. This appliance is only for use with the type of gas indicated on the rating plate. This appliance is not convertible for use with other gases unless a certified kit is used.
3 106706 OWNER’S MANUAL For more information, visit www.desatech.com PRODUCT IDENTIFICA TION Install and use stove and burner system with care. Follow all local codes. In the absence to local codes, use the current National Fuel Gas Code ANS Z223.1 , also known as NFPA 54* (USA) or the current CAN/CGA- B149[.
4 CAST IRON STOVE AND BURNER SYSTEM 106706 SUN V ALLEY STOVE COMP ANY For more information, visit www.desatech.com LOCATION AND SPACE REQUIREMENTS Determine the safest and most efficient loca- tion for your Sun Valley B-vent freestanding stove. Make sure that rafters and wall studs are not in the way of the venting system.
5 106706 OWNER’S MANUAL For more information, visit www.desatech.com STOVE BODY ASSEMBLY 1. Lift off corrugated box enclosing stove body crating. 2. Remove all screws fastening the wood frame enclosure. Spread wood frame open and lift away from plastic-bagged stove body .
6 CAST IRON STOVE AND BURNER SYSTEM 106706 SUN V ALLEY STOVE COMP ANY For more information, visit www.desatech.com CAST IRON STOVE AND B-VENT BURNER SYSTEM ASSEMBL Y Continued 9. Attach stove door by inserting step bolt through door hinge pivot hole and into threaded hole in stove body (see Fig- ure 9, page 5 and Figure 1 1).
7 106706 OWNER’S MANUAL For more information, visit www.desatech.com CAST IRON STOVE AND B-VENT BURNER SYSTEM ASSEMBL Y Continued Continued INSTALLING B-VENT BURNER SYSTEM INTO STOVE BODY 1. Carefully lift burner system and place into stove body from the rear of stove (see Figure 16).
8 CAST IRON STOVE AND BURNER SYSTEM 106706 SUN V ALLEY STOVE COMP ANY For more information, visit www.desatech.com CAST IRON STOVE AND B-VENT BURNER SYSTEM ASSEMBL Y Continued INSTALLING REAR COVER 1 . Place rear cover behind stove body . Rear cover will rest on the bottom ledge of the stove body .
9 106706 OWNER’S MANUAL For more information, visit www.desatech.com CAST IRON STOVE AND B-VENT BURNER SYSTEM ASSEMBL Y Continued WARNING: A qualified in- staller or service person must connect burner system to gas supply. Follow all local codes. INSTALLATION PRECAUTIONS Consult local building codes before begin- ning the installation.
10 CAST IRON STOVE AND BURNER SYSTEM 106706 SUN V ALLEY STOVE COMP ANY For more information, visit www.desatech.com WARNING: Installation should only be made by qualified per- sons who are familiar wi.
11 106706 OWNER’S MANUAL For more information, visit www.desatech.com VENTING INST ALLA TION Continued Continued • Complete familiarity with chimney con- dition, height, size, clearance to combus- tibles and other factors is essential.
12 CAST IRON STOVE AND BURNER SYSTEM 106706 SUN V ALLEY STOVE COMP ANY For more information, visit www.desatech.com TROUBLESHOOTING VENTING PROBLEMS Most venting problems are caused by incor- rect vent sizing, improper installation, or inadequate air supply.
13 106706 OWNER’S MANUAL For more information, visit www.desatech.com Installation Items Needed Before installing stove and burner system, make sure you have the items listed below.
14 CAST IRON STOVE AND BURNER SYSTEM 106706 SUN V ALLEY STOVE COMP ANY For more information, visit www.desatech.com Pressure Testing Gas Supply Piping System Test Pressures In Excess Of 1/2 PSIG (3.5 kPa) 1. Disconnect appliance with its appliance main gas valve (control valve) and equipment shutoff valve from gas supply piping systems.
15 106706 OWNER’S MANUAL For more information, visit www.desatech.com STOVE AND B-VENT BURNER SYSTEM INST ALLA TION Continued Continued Figure 34 - Checking Gas Joints for Propane/LP Gas Burner Syst.
16 CAST IRON STOVE AND BURNER SYSTEM 106706 SUN V ALLEY STOVE COMP ANY For more information, visit www.desatech.com INSTALLING OPTIONAL WIRELESS HAND-HELD REMOTE CONTROL ACCESSORIES - GHRC AND GHRCTA .
17 106706 OWNER’S MANUAL For more information, visit www.desatech.com REMOVING/REPLACING GLASS DOOR CAUTION: Do not operate this burner system with a broken glass door panel or without the glass door panel securely in place. For replacement part in- formation see Replacement Parts , page 26.
18 CAST IRON STOVE AND BURNER SYSTEM 106706 SUN V ALLEY STOVE COMP ANY For more information, visit www.desatech.com It is very important to install these logs exactly as instructed. Do not modify logs. Only use logs supplied with freestanding stove with burner system.
19 106706 OWNER’S MANUAL For more information, visit www.desatech.com TO TURN OFF GAS TO APPLIANCE 1. Set selector switch, located on side of rear panel, in the “OFF” position. 2a. Open lower door panel. 2b . If Using Optional Hand-Held Remote: Set selector switch in the OFF posi- tion to pre vent draining battery .
20 CAST IRON STOVE AND BURNER SYSTEM 106706 SUN V ALLEY STOVE COMP ANY For more information, visit www.desatech.com 1. After lighting, let pilot flame bur n f or about one minute. T urn control knob on the control v alve to ON position. T urn flame adjustment knob any- where between HI and LO.
21 106706 OWNER’S MANUAL For more information, visit www.desatech.com INSPECTING BURNERS Check pilot flame pattern and burner flame patterns often. PILOT ASSEMBLY The pilot assembly is factory preset for the proper flame height. Alterations may have occurred during shipping and handling.
22 CAST IRON STOVE AND BURNER SYSTEM 106706 SUN V ALLEY STOVE COMP ANY For more information, visit www.desatech.com CLEANING AND MAINTENANCE WARNING: Turn off burner sys- tem and let cool before cleaning. CAUTION: You must keep con- trol areas, burners, and circulat- ing air passageways of stove and burner system clean.
23 106706 OWNER’S MANUAL For more information, visit www.desatech.com TROUBLESHOOTING Note: All troubleshooting items are listed in order of operation. WARNING: Turn off heater and let cool before servicing. Only a qualified service person should service and repair heater.
24 CAST IRON STOVE AND BURNER SYSTEM 106706 SUN V ALLEY STOVE COMP ANY For more information, visit www.desatech.com OBSERVED PROBLEM Burner does not light after pilot is lit Delayed ignition burner Bu.
25 106706 OWNER’S MANUAL For more information, visit www.desatech.com TROUBLESHOOTING Continued WARNING: If you smell gas • Shut off gas supply. • Do not try to light any appliance. • Do not touch any electrical switch; do not use any phone in your building.
26 CAST IRON STOVE AND BURNER SYSTEM 106706 SUN V ALLEY STOVE COMP ANY For more information, visit www.desatech.com SER VICE HINTS When Gas Pressure is Too Low • pilot will not stay lit • burners .
27 106706 OWNER’S MANUAL For more information, visit www.desatech.com SPECIFICA TIONS MSRBVN MSRBVP 21,000-30,000 Btu/h 20,000-28,000 Btu/h Gas Type Natural Propane/LP Ignition Piezo Piezo Manifold Pressure 3.5" w.c. 10.0" w.c. Minimum Inlet Supply Pressure 4.
28 CAST IRON STOVE AND BURNER SYSTEM 106706 SUN V ALLEY STOVE COMP ANY For more information, visit www.desatech.com ILLUSTRA TED PA R T S BREAKDOWN MSRBVN MSRBVP L O H I P I L O T O F F O N 4 4 17 18 .
29 106706 OWNER’S MANUAL For more information, visit www.desatech.com P ARTS LIST MSRBVN MSRBVP This list contains replaceable parts used in your fireplace. When ordering parts, follow the instructions listed under Replacement Parts on page 26 of this manual.
30 CAST IRON STOVE AND BURNER SYSTEM 106706 SUN V ALLEY STOVE COMP ANY For more information, visit www.desatech.com ILLUSTRA TED PA R T S BREAKDOWN SUN VALLEY STOVE MC(*) SERIES (* Indicates Color Suf.
31 106706 OWNER’S MANUAL For more information, visit www.desatech.com P ARTS LIST SUN VALLEY STOVE MC(*) SERIES (* Indicates Color Suffix Designation) This list contains replaceable parts used in your stove. When ordering parts, follow the instructions listed under Replacement Parts on page 26 of this manual.
LIMITED WARRANTY B-VENT FREESTANDING FIREPLACE AND SUN VALLEY STOVE CHASSIS DESA International warrants this product to be free from defects in materials and components for four (4) years from the date of first purchase, provided that the product has been properly installed, operated and maintained in accordance with all applicable instructions.
An important point after buying a device Desa MSRBVP (or even before the purchase) is to read its user manual. We should do this for several simple reasons:
If you have not bought Desa MSRBVP yet, this is a good time to familiarize yourself with the basic data on the product. First of all view first pages of the manual, you can find above. You should find there the most important technical data Desa MSRBVP - thus you can check whether the hardware meets your expectations. When delving into next pages of the user manual, Desa MSRBVP you will learn all the available features of the product, as well as information on its operation. The information that you get Desa MSRBVP will certainly help you make a decision on the purchase.
If you already are a holder of Desa MSRBVP, but have not read the manual yet, you should do it for the reasons described above. You will learn then if you properly used the available features, and whether you have not made any mistakes, which can shorten the lifetime Desa MSRBVP.
However, one of the most important roles played by the user manual is to help in solving problems with Desa MSRBVP. Almost always you will find there Troubleshooting, which are the most frequently occurring failures and malfunctions of the device Desa MSRBVP along with tips on how to solve them. Even if you fail to solve the problem, the manual will show you a further procedure – contact to the customer service center or the nearest service center
