Instruction/ maintenance manual of the product CCL3018NR Desa
Go to page of 32
UNVENTED (VENT -FREE) GAS LOG HEA TER OWNER’S OPERATION AND INSTALLATION MANUAL For more information, visit www.desatech.com For more information, visit www.
111161-01A 2 For more information, visit www.desatech.com For more information, visit www.desatech.com TABLE OF CONTENTS SAFETY INFORMATION SAFETY INFORMA TION WARNINGS WARNING: This product contains and/or generates chemicals known to the State of California to cause cancer or birth defects, or other reproductive harm.
111161-01A 3 3 For more information, visit www.desatech.com For more information, visit www.desatech.com SAFETY INFORMATION PRODUCT IDENTIFICATION 1. This appliance is only for use with the type of gas indicated on the rating plate. This appliance is not convertible for use with other gases.
111161-01A 4 For more information, visit www.desatech.com For more information, visit www.desatech.com LOCAL CODES Install and use heater with care. Follow all local codes. In the absence of local codes, use the latest edition of The National Fuel Gas Code, ANSI Z223/NFPA 54*.
111161-01A 5 5 For more information, visit www.desatech.com For more information, visit www.desatech.com Unusually Tight Construction The air that leaks around doors and windows may provide enough fresh air for combustion and ventilation. However, in buildings of unusually tight construction, you must provide additional fresh air.
111161-01A 6 For more information, visit www.desatech.com For more information, visit www.desatech.com WARNING: If the area in which the heater may be operated is smaller than that defined as an uncon.
111161-01A 7 7 For more information, visit www.desatech.com For more information, visit www.desatech.com INSTALLATION Check Gas Type Installation and Clearances INST ALLA TION WARNING: A qualified service person must in- stall heater. Follow all local codes.
111161-01A 8 For more information, visit www.desatech.com For more information, visit www.desatech.com Minimum Clearances for Side Combustible Material, Side Wall, and Ceiling A. Clearances from the side of the fireplace cabinet to any com- bustible material and wall should follow diagram in Figure 4.
111161-01A 9 9 For more information, visit www.desatech.com For more information, visit www.desatech.com MANTEL CLEARANCES In addition to meeting noncombustible material clearances, you must also meet required clearances between fireplace opening and mantel shelf.
111161-01A 10 For more information, visit www.desatech.com For more information, visit www.desatech.com INST ALLA TION Continued INSTALLATION Installing Damper Clamp Accessory For Vented Operation Ins.
111161-01A 11 11 For more information, visit www.desatech.com For more information, visit www.desatech.com INST ALLA TION Continued INSTALLATION Installing Heater Base Assembly (Cont.
111161-01A 12 For more information, visit www.desatech.com For more information, visit www.desatech.com WARNING: Use pipe joint sealant that is resistant to liquid petroleum (LP) gas. CAUTION: Avoid damage to regulator. Hold gas regulator with wrench when connecting it to gas piping and/or fittings.
111161-01A 13 13 For more information, visit www.desatech.com For more information, visit www.desatech.com INST ALLA TION Continued 5. Correct all leaks at once. 6. Reconnect heater and equipment shutoff valve to gas supply . Check reconnected fittings for leaks.
111161-01A 14 For more information, visit www.desatech.com For more information, visit www.desatech.com INSTALLATION Installing Wireless Remote Control Accessory Installing Logs (Models CCL3018PR, CCL.
111161-01A 15 15 For more information, visit www.desatech.com For more information, visit www.desatech.com INSTALLATION Installing Logs (Models CCL3018PR, CCL 3018NR, CCL3924 PR, CCL3924NR, CCL3930PR, AND CCL3930NR ) (Cont.) A U T O O F F O N 3. Locate pegs on the bottom of back log (#3).
111161-01A 16 For more information, visit www.desatech.com For more information, visit www.desatech.com OPERATING HEATER For Your Safety Read Before Lighting Lighting Instructions WARNING: If you do not follow these instructions exactly, a fire or explosion may result causing prop- erty damage, personal injury or loss of life.
111161-01A 17 17 For more information, visit www.desatech.com For more information, visit www.desatech.com CAUTION: Do not try to adjust heating levels by using the equipment shutoff valve. WARNING: Make sure the selector switch is in the OFF position when you are away from home for long periods of time.
111161-01A 18 For more information, visit www.desatech.com For more information, visit www.desatech.com OPERATING HEATER Optional Remote Operation (Cont.) INSPECTING BURNERS Pilot Flame Pattern Main Burner WIRING DIAGRAM CGHRCTA Series Operation: 2b .
111161-01A 19 19 For more information, visit www.desatech.com For more information, visit www.desatech.com CLEANING AND MAINTENANCE WARNING: Turn off heater and let cool before cleaning. CAUTION: You must keep control areas, burner, and circulating air passageways of heater clean.
111161-01A 20 For more information, visit www.desatech.com For more information, visit www.desatech.com TROUBLESHOOTING TROUBLESHOOTING WARNING: Turn off heater and let cool before servicing. Only a qualified service person should service and repair heater.
111161-01A 21 21 For more information, visit www.desatech.com For more information, visit www.desatech.com OBSERVED PROBLEM Burner does light after ODS/pilot is lit Delayed ignition burner Burner back.
111161-01A 22 For more information, visit www.desatech.com For more information, visit www.desatech.com TROUBLESHOOTING Continued WARNING: If you smell gas • Shut off gas supply. • Do not try to light any appliance. • Do not touch any electrical switch; do not use any phone in your building.
111161-01A 23 23 For more information, visit www.desatech.com For more information, visit www.desatech.com TECHNICAL SER VICE You may have further questions about installation, operation, or troubleshooting. If so, contact DESA International’s Technical Service Department at 1-866-672-6040.
111161-01A 24 For more information, visit www.desatech.com For more information, visit www.desatech.com ILLUSTRATED PARTS BREAKDOWN Models CCL3018PR, CCL3018PRA, CCL3018NR and CCL3018NRA ILLUSTRA TED .
111161-01A 25 25 For more information, visit www.desatech.com For more information, visit www.desatech.com PARTS LIST Models CCL3018PR, CCL3018PRA, CCL3018NR and CCL3018NRA P ARTS LIST This list contains replaceable parts used in your heater. When ordering parts, follow the instructions listed under Replacement Parts on page 23 of this manual.
111161-01A 26 For more information, visit www.desatech.com For more information, visit www.desatech.com 30 18 19 27 18 23 12 11 14 4 5 1 2 17 10 21 20 22 6 7 3 9 16 8 15 29 28 28 25 26 O F F P I L O T.
111161-01A 27 27 For more information, visit www.desatech.com For more information, visit www.desatech.com PAR TS LIST This list contains replaceable parts used in your heater. When ordering parts, follow the instructions listed under Replacement Parts on page 23 of this manual.
111161-01A 28 For more information, visit www.desatech.com For more information, visit www.desatech.com ACCESSORIES Purchase these fireplace accessories from your local dealer.
111161-01A 29 29 For more information, visit www.desatech.com For more information, visit www.desatech.com 1. Where will the product be used? ❍ Living/Family Room ❍ Office/W arehouse ❍ Utility Shed/Outbuilding ❍ Garage ❍ Bedroom ❍ Bathroom ❍ Other 2.
111161-01A 30 For more information, visit www.desatech.com For more information, visit www.desatech.com 2701 Industrial Drive P.O. Box 90004 Bowling Green, KY 42102-9004 Postage Required TM T APE T AP.
111161-01A 31 31 For more information, visit www.desatech.com For more information, visit www.desatech.com NOTES _______________________________________________________________________________________.
111161-01A 32 For more information, visit www.desatech.com For more information, visit www.desatech.com LIMITED WARRANTY COMFORT GLOW VENT-FREE GAS LOG HEATERS DESA International warrants this product.
An important point after buying a device Desa CCL3018NR (or even before the purchase) is to read its user manual. We should do this for several simple reasons:
If you have not bought Desa CCL3018NR yet, this is a good time to familiarize yourself with the basic data on the product. First of all view first pages of the manual, you can find above. You should find there the most important technical data Desa CCL3018NR - thus you can check whether the hardware meets your expectations. When delving into next pages of the user manual, Desa CCL3018NR you will learn all the available features of the product, as well as information on its operation. The information that you get Desa CCL3018NR will certainly help you make a decision on the purchase.
If you already are a holder of Desa CCL3018NR, but have not read the manual yet, you should do it for the reasons described above. You will learn then if you properly used the available features, and whether you have not made any mistakes, which can shorten the lifetime Desa CCL3018NR.
However, one of the most important roles played by the user manual is to help in solving problems with Desa CCL3018NR. Almost always you will find there Troubleshooting, which are the most frequently occurring failures and malfunctions of the device Desa CCL3018NR along with tips on how to solve them. Even if you fail to solve the problem, the manual will show you a further procedure – contact to the customer service center or the nearest service center
