Instruction/ maintenance manual of the product OBSB162 Dacor
Go to page of 24
Installa tion Instr uc tion s Epi cu re ® Outdoor Gri ll Models: OB36, OBS36, OB52, OBS52 and OBSB162 Part No. 102032 Rev . K TESTED IN ACCORDANCE WITH THE LA TEST EDITION OF .
Before Y ou Begin... Customer Ser vice Infor mation All specifications subject to change without notice. Dacor assumes no liability for changes to specifications.
1 Impor tant Infor mation About Safety Instructions The • Important Safety Instructions and warnings in these instructions are not meant to cover all possible problems and conditions that can occur . Use common sense and caution when installing, maintaining or oper- ating this or any other appliance.
2 Impor tant Safety Instructions Read the use and care manual completely before • using this appliance. Use this appliance only for its intended use as • described in the use and care manual. Use it only to cook food. It is not designed for commercial, indus- trial or laboratory use.
3 Impor tant Safety Instructions W ARNING Do not leave children alone or unattended in the area • around the appliance. Do not allow children to oper- ate it, play with the controls, pull on the handle or touch other parts. Do not store items of interest to children on top of • or above the appliance.
4 9 1/8" (232mm) 23 3/4" (603mm) 26 1/2" (673mm) 27” * (686mm) 36" (914mm) 25 1/8" (638mm) Product Dimensions Planning the Installation 9 1/8" (232mm) 23 3/4" (603.
5 Planning the Installation 9 1/8" *** (232mm) 23 3/4" (603mm) 26 1/2" (673mm) 27" ** (686mm) 16" (406mm) Cut-out for outdoor grill Overall height Overall width ** T otal dept.
6 Planning the Installation Location Planning - General Gas and Electric Power Requirements Prior to installation, the gas supply for natural gas or • whole house LP installations must meet the specifica- tions below .
7 Planning the Installation Location Planning - Enclosed Cabinets Maintain all minimum clearances specified on pages 7 • and 8. For proper outdoor grill operation, provide a flat, level • mounting surface with minimum 3/4” thickness.
8 Planning the Installation Location Planning - Enclosed Cabinets (continued) 3/8" (10mm)ø Both sides 6" x 7" (152mm x 178mm) utility cutout Coutertop 25" (635mm) 24" (610mm) 8" (203mm) Min.
9 Planning the Installation Location Planning - Car t Installations Example of Grill Cart Location Maintain all minimum clearances shown between the • appliance and all surfaces behind and to the side of the appliance. Allow 26 inches minimum in front to open and close the • cabinet drawers.
10 Par ts List Models OB36, OBS36, OB52 and OBS52: A Drip tray G Rotisserie rod and forks B Smoker box H Rotisserie motor C Warming rack Match holder D Regulator assembly Cleaning cream E Grills F Fla.
11 Installation Instructions D E H L L M N P K F G D D Whole house natural gas or LP regulator* LP cylinder regulator OBS162, OB36 and OBS36 (PN 72310) LP cylinder regulator OB52 and OBS52 (PN 101578) * A whole house gas regulator comes standard with natural gas models.
12 Car t Installation W ARNING Attach the appliance to the cart with all of the supplied • bolts before use. All gas and electrical connections should be made • after the grill is installed and bolted to the cart.
13 Optional Side Shelf Installation Install the front mounting bracket for the right side 1. shelf. Use two (2) of the provided button head fasten- ers and two (2) lock washers. Tighten into place using a 5/32” Allen wrench. Slide the slot on the inside of the shelf over the pin on 2.
14 Install an approved flexible gas line from the regulator 3. to the gas shut-off valve. Gas Connection - LP Gas Cylinder Hose Connect the supplied 3/4” coupling and nipple to the 1. gas inlet at the back right bottom corner of the unit. Connect the included LP cylinder hose to the nipple.
15 Installation Instructions Final Assembly and T est Assemble the Grill Open the canopy on the unit. 1. Insert the drip tray completely into the slot on the front 2. of the unit. Put the flame spreaders on the floor of the appliance, 3. inside the canopy .
16 Installation Instructions Final Assembly and T est (cont.) LP Cylinder Installation - Some Models W ARNING The largest recommended LP cylinder size for the • rollout tank shelf on the cart is five gallons. A five gallon portable liquid propane cylinder should be approximately 12 inches (305mm) in diameter and 18 inches (457mm) high,.
17 If the second or third attempt to ignite the burner is 6. not successful then turn all burner controls to the OFF position. If the grill or cooktop fails to operate properly , make 7. sure that power to the electrical outlet and gas supply are turned on and that all installation steps have been carefully followed.
18 W iring Diagrams .
19 W iring Diagrams .
20 Notes.
21.
Dacor●600 AntonBlvd.Suite1000CostaMesa,CA 92626●Phone:(800)793-0093●Fax:(626)403-3130●www .
An important point after buying a device Dacor OBSB162 (or even before the purchase) is to read its user manual. We should do this for several simple reasons:
If you have not bought Dacor OBSB162 yet, this is a good time to familiarize yourself with the basic data on the product. First of all view first pages of the manual, you can find above. You should find there the most important technical data Dacor OBSB162 - thus you can check whether the hardware meets your expectations. When delving into next pages of the user manual, Dacor OBSB162 you will learn all the available features of the product, as well as information on its operation. The information that you get Dacor OBSB162 will certainly help you make a decision on the purchase.
If you already are a holder of Dacor OBSB162, but have not read the manual yet, you should do it for the reasons described above. You will learn then if you properly used the available features, and whether you have not made any mistakes, which can shorten the lifetime Dacor OBSB162.
However, one of the most important roles played by the user manual is to help in solving problems with Dacor OBSB162. Almost always you will find there Troubleshooting, which are the most frequently occurring failures and malfunctions of the device Dacor OBSB162 along with tips on how to solve them. Even if you fail to solve the problem, the manual will show you a further procedure – contact to the customer service center or the nearest service center
