Instruction/ maintenance manual of the product LP Gas Grill Char-Broil
Go to page of 32
T o installer or person assembling grill: Leave this manual with grill for future reference. T o consumer: Keep this manual for future reference. This manual applies to a variety of grill styles.
2 FOR YOUR SAFETY 1. Do not store or use gasoline or other flammable vapors and liquids in the vicinity of this or any other appliance. 2. An LP tank not connected for use shall not be stored in the vicinity of this or any other appliance. FOR YOUR SAFETY If you smell gas: 1.
3 For Y our Safety .........................................................................2 Call Grill Service Center For Help and Parts ...................................................2 Fill Out W arranty Information ............................
4 D ANGER Safety Symbols The symbols and boxes shown below explain what each heading means. Read and follow all of the messages found throughout the manual. DANGER: Indicates an imminently hazardous situation which, if not avoided, will result in death or serious injury .
5 D ANGER • Never fill the cylinder beyond 80% full. An overfilled LP tank is hazardous due to possible gas released from the safety relief valve. • The safety relief valve on the LP tank could activate releasing gas and cause an intense fire with risk of property damage, serious injury or death.
LP (Liquefied Petroleum Gas) • For Y our Safety • LP gas is nontoxic, odorless and colorless when produced. , LP gas has been given an odor (similar to rotten cabbage) so that it can be smelled. LP gas is highly flammable and may ignite unexpectedly when mixed with air .
Do not use a POL transport plug (plastic part with external threads)! It will defeat the safety feature of the valve. 7 Straight Hold coupling nut and regulator as shown for proper connection to LP tank valve. 6. An additional one-half to three- quarters turn is required to complete the connection.
8 Sideburner Valve s Never remove opening at end of valve. HeatWave Hose (if featured) 5. If “growing” If leaks cannot be stopped “do not try to repair” 6. bubbles appear , there is a leak. Close LP tank valve immediately and re-tighten connections.
WARNING For Safe Use Of Y our Grill And T o A void Serious Injury: • • • • • • Use grill at least 3 ft. from any wall or surface. • Apartment Dwellers: • NEVER attempt to light burner with lid closed. A buildup of non-ignited gas inside a closed grill is hazardous.
10 Ignitor Lighting: Performance and Advantage Series T wo Burner Grill: s s s s T urn on gas at LP tank. T urn left knob to . Push and hold Electronic Ignitor button. If ignition does NOT occur in 5 seconds, turn the burner controls off, wait 5 minutes and repeat the lighting procedure.
HIGH LOW Burner Flame Check • Light burner , rotate knob(s) from HIGH to LOW . Y ou should see a smaller flame in LOW position than seen on HIGH. Always check flame prior to each use. Perform flame check on sideburner (if equipped). If only low flame is seen refer to "Sudden drop or low flame" in the .
12 Cleaning The T raditional Series, QuickSet and QuickSet T raditional Burner Assembly Follow these instructions to clean and/or replace parts of burner assembly or if you have trouble igniting the grill.
13 Remove button and battery on electronic ignition models QuickSet Burner Electrode Burner T ube V alve Clip Short Ignitor Wire A B C.
14 Cleaning The Performance and Advantage Burner Assembly Follow these instructions to clean and/or replace parts of burner assembly or if you have trouble igniting the grill. 1. 2. Remove cooking grids and vaporizer tents. 3. Remove two pal nuts, carry-over tube and burners.
15 A Burner tubes correctly engaged in valves Burner T ube V alve Burner Carry-Over T ube V aporizer T ents Pal Nuts.
16 Burner T ube C Housing Burner Portholes Gas T ube B Gas T ube Burner T ube Ignitor Wire Electrode Hitch Pin Hinge Pin Thumbscrew Shield BACK OF GRILL Rotisserie Burner Hitch Pin Hinge Pin A D Cleaning The Rotisserie Burner Follow these instructions to clean and/or replace parts of burner assembly or if you have trouble igniting the grill.
17 Rotisserie Burner Use The rotisserie burner is a 10,500 BTU radiant heat burner that transforms your grill into a multilevel cooking center . It is attached to the back of the bottom casting, above the main grid. Y ou can use the burner as a broiler to cook foods on the cooking grates or bonus-grid.
18 General Grill Cleaning • Keep the outside of your grill looking new by cleaning it once a month with warm soap and water or a non-abrasive cleaner . If you don’t have a grill cover , wipe off dust and grime before starting your grill. • Do not mistake brown or black accumulation of grease and smoke for paint.
19 Care And Cleaning Of Stainless Steel Routine cleaning is necessary to preserve the appearance and corrosion resistance of Stainless Steel. The methods below are suggestions for cleaning stainless steel surfaces. Choose a cleaning method appropriate to the requirement.
CA UTION F ACT : Sometimes spiders and other small insects climb into the burner tubes attached to the burner . The spiders spin webs, build nests and lay eggs. The webs or nests can be very small, but they are very strong and can block the flow of gas.
Charcoal/Gas Grills If you haven’t attached the handles to the grate follow step 1. . Step 1. • • Left handle is shown in the correct position between second and third wire from end. Hook end of right handle over back and pull to hook over front wire.
Cooking Chart Cooking times and temperatures may vary according to specific recipes, cooking conditions or barbecue equipment used. T ake these factors into consideration to insure best results.
Food Safety Storing Y our Grill • Food safety is a very important part of enjoying the outdoor cooking experience. T o keep food safe from harmful bacteria, follow these four basic steps: W ash hands, utensils and surfaces with hot soapy water before and after handling raw meat and poultry .
Troubleshooting Emergencies Problem Gas leaking from cracked/cut/burned hose. Gas leaking from LP tank. Gas leaking from LP tank valve. Gas leaking between LP tank and regulator connection. Fire coming through control panel. Grease fire or continuous excessive flames above cooking surface.
Troubleshooting ( ) continued Problem Burner(s) will not light using ignitor . (See Electronic Ignition T roubleshooting also) Burner(s) will not match light. Sudden drop in gas flow or low flame. Flames blow out. Flare-up. Persistent grease fire. Flashback.
Troubleshooting - Electronic Ignition Problem (Ignition) SECTION I SECTION II SECTION III No sparks appear at any electrodes when ignition button is pushed; no noise can be heard from spark module. No sparks appear at any electrodes when ignition switch is pushed; noise can be heard from spark module.
Recipes by Chef Christopher Koetke, CEC, CCE Five-Spice Grilled Duck Breast with Asian BBQ Sauce Asian BBQ Sauce Ratatouille Melts Serves 4 4 boneless skinless duck breasts 1 garlic clove, minced 2 teas. finely grated orange zest 1-1/2 teas. five spice mix 1-1/2 teas.
Char-Broil T urkey Giblet Gravy Smoked T urkey Breast Y ield: 14 to 16 generous servings or 1 lb. per person Cooking time: 25 minutes per pound • Method: Grill on low 12 to 14 lb.
29.
30 Please register your grill online at: (If you register online, you do not need to send in this registration card.) WWW .GRILLREGISTRA TION.COM.
31 Certified Grill Parts And Accessories®, Char-Broil and Design®, Char-Broil (Gas Grill Briquettes)®, Char-Diamonds®, Cooking Zone and Design®, Diamond Flame®, Executive Chef®, Faststart®, Fl.
ST OP Should you encounter any problem Do not return this product to the store. 24 Hours a Da y - 7 Days a week Read all Owner ’s Manuals Complete W arranty Card Ensure valves are correctly installe.
An important point after buying a device Char-Broil LP Gas Grill (or even before the purchase) is to read its user manual. We should do this for several simple reasons:
If you have not bought Char-Broil LP Gas Grill yet, this is a good time to familiarize yourself with the basic data on the product. First of all view first pages of the manual, you can find above. You should find there the most important technical data Char-Broil LP Gas Grill - thus you can check whether the hardware meets your expectations. When delving into next pages of the user manual, Char-Broil LP Gas Grill you will learn all the available features of the product, as well as information on its operation. The information that you get Char-Broil LP Gas Grill will certainly help you make a decision on the purchase.
If you already are a holder of Char-Broil LP Gas Grill, but have not read the manual yet, you should do it for the reasons described above. You will learn then if you properly used the available features, and whether you have not made any mistakes, which can shorten the lifetime Char-Broil LP Gas Grill.
However, one of the most important roles played by the user manual is to help in solving problems with Char-Broil LP Gas Grill. Almost always you will find there Troubleshooting, which are the most frequently occurring failures and malfunctions of the device Char-Broil LP Gas Grill along with tips on how to solve them. Even if you fail to solve the problem, the manual will show you a further procedure – contact to the customer service center or the nearest service center
