Instruction/ maintenance manual of the product 5000 Aprilaire
Go to page of 12
1 Model 5000 Electronic Air Cleaner Installation Instructions WARNING 120 Volts may cause serious injury from electrical shock. Disconnect power to the furnace/air handler before starting installation. Leave power disconnected until installation is completed.
2 31" with Door 28-1/8" without Door 12" 24-5/8" 23-7/8" 15-1/2" 17-3/4" 18-3/8" 15-1/2" FIGURE 1 – Dimensions of the Model 5000 Electronic Air Cleaner 90-1346 SPECIFICA TIONS TABLE 2 – Model 5000 Initial Airflow Resistance (inches w.
3 Pleat Spacers (6) #501 Media Outer Housing with Door Retainers Inner Housing Assembly Inner Housing Ionizer Frame Control Electrode Power Pack/Door Assembly On/Off Switch Latches 90-1152 FIGURE 2 .
4 LOCATING THE AIR CLEANER Airflow Airflow Airflow Airflow 30 max. 45 max. Minimize Angles Where Possible Airflow Plenum Box Airflow Plenum Box Size Plenum Box to fit outer housing without door: 17-3/4” x 28-1/8” . See Figure 1 for complete dimensions.
5 1. Turn the system OFF at the thermostat by changing the mode selector to OFF – this may be a switch or a pushbutton, depending on the type of thermostat. 2. Disconnect power service to the furnace or air handler. 3. Remove air cleaner power pack / door assembly and pull inner assembly out of the outer housing.
6 WIRING AND START UP 1. Install a grounded (earth ground) 120-volt single receptacle outlet in accordance with NEC Standards and local codes, into which the EAC will be plugged. This outlet is to be live only when the furnace/air handler blower is running.
7 EA C NEUTRAL GND HV AC Equipment Control Center Circuit Board IT IS COMMON TO SEE SP ADE TERMINALS ON THE HV AC EQUIPMENT CONT RO L CENTER CIRCUIT BOARD .
8 TROUBLESHOOTING GUIDE PROBLEM POSSIBLE CAUSE(S) SOLUTION(S) Light does not come on at all after 90 seconds ON/OFF switch not in ON position Turn switch ON.
9 MAINTENANCE RECOMMENDATIONS Whenever performing maintenance on the air cleaner, turn off the HVAC system, then turn off and unplug the air cleaner. Before performing any maintenance item listed below: 1.
10 Inner Housing Ionizer Fram e Control Electrode Control Electrode Ionizer Frame Control Electrode Ground Contact Media Ground Contacts Ionizer Wires Bus Bar FIGURE 16 – Maintenance 90-1151.
11 APPLICATIONS WITH A HUMIDIFIER An Aprilaire ® Automatic Humidifier can be mounted upstream from the air cleaner. CAUTION Do not install an atomizing humidifier upstream from the air cleaner.
P.O. Box 1467 • Madison, WI 53701-1467 • Phone: 800/334-6011 • Fax: 608/257-4357 • www.aprilairepartners.com 10007971 2.14 B2701048B Printed in U.
An important point after buying a device Aprilaire 5000 (or even before the purchase) is to read its user manual. We should do this for several simple reasons:
If you have not bought Aprilaire 5000 yet, this is a good time to familiarize yourself with the basic data on the product. First of all view first pages of the manual, you can find above. You should find there the most important technical data Aprilaire 5000 - thus you can check whether the hardware meets your expectations. When delving into next pages of the user manual, Aprilaire 5000 you will learn all the available features of the product, as well as information on its operation. The information that you get Aprilaire 5000 will certainly help you make a decision on the purchase.
If you already are a holder of Aprilaire 5000, but have not read the manual yet, you should do it for the reasons described above. You will learn then if you properly used the available features, and whether you have not made any mistakes, which can shorten the lifetime Aprilaire 5000.
However, one of the most important roles played by the user manual is to help in solving problems with Aprilaire 5000. Almost always you will find there Troubleshooting, which are the most frequently occurring failures and malfunctions of the device Aprilaire 5000 along with tips on how to solve them. Even if you fail to solve the problem, the manual will show you a further procedure – contact to the customer service center or the nearest service center
